Home Projects
Project Listing Sort view by:
select

  • “Fokus” Building

    Warsaw, Poland

    Xypex Concentrate was applied to a 133 m strip between the top plate and the sheet pile wall.

    Read More

  • 102 University Avenue

    Palo Alto, California, USA

    The use of concrete as a design element has always appealed to architects. However, concern over water seepage, efflorescence and rebar corrosion has often held them back. Faced with this issue, Joseph Bellomo Architects used the crystalline waterproofing and protection features of Xypex in an innovative concrete mix on their new LEED Platinum project in Palo Alto, California.

    Read More

  • 21st Century Tower

    Dubai, United Arab Emirates

    This tower is the tallest residential building in the region. Xypex was used to waterproof and protect the underground water tanks.

    Read More

  • 313@Somerset

    Singapore

    Engineers, Meinhardt Infrastructure, faced many design challenges including a canal that ran through the centre of the building site, a very high water table and greatly elevated sulphate levels in the surrounding soils.

    Read More

  • 409 and 499 Illinois

    San Francisco, California, USA

    With an especially high water table at 8 feet below grade, the possibility of saltwater attack, and a garage design calling for two parking levels at 30-ft below grade, developers faced a far greater concrete waterproofing and protection issue than normal.

    Read More

  • 88 Wood Street Tunnel

    London, United Kingdom

    The joints of the pre-cast unit, and the basement core on level 4 of this service tunnel suffered water ingress. During the repair of the tunnel, water ingress measured 3500 litres/hour and the entire area was under 44 millimetres of water during the rainy season. All joints were treated with Xypex Patch'n Plug, Xypex Dry-Pac and Xypex FCM. Xypex Admix C-1000 NF was then used in the new concrete fill.

    Read More

  • A.G.I.R. Building

    Bucharest, Romania

    A 10 cm cantilever slab at the entrance of the building was damaged by freeze/thaw action.

    Read More

  • AASS Wastewater Treatment Plant

    Entre Rios, Ecuador

    The walls of this plant were cast using the Machihembrado method. Because of this approach, Xypex Dry-Pac and Xypex Patch'n Plug were required to seal the construction joints. The same Xypex treatment was used on 518 m of cold joints and cracks. After these structural defects were repaired, the surfaces were treated with a two-coat application of Xypex Concentrate.

    Read More

  • Abiquiu Dam

    Espanola, Mexico

    Xypex Concentrate and Modified were applied to the power house and gate operator building at this dam on the Rio Grande River in New Mexico. The Xypex products were specified by Tudor Engineering of San Francisco and the application was performed by personnel of Bechtel Construction Co, the prime contractor for the project.

    Read More

  • Aguas De Cartagena

    Cartegena, Colombia

    This old reservoir in the Industrial Sector of Cartagena de Indias, was completely restored with Xypex products. The marine environment had affected all the concrete and part of the steel reinforcement. Before the application of Xypex, the corroded material on the beams, columns and reservoir was removed. Xypex Concentrate was then applied to the surface. Xypex Admix treated mortars were also used for repairs throughout the whole structure.

    Read More

  • Ajaz Zone 2 Reservoir

    Ajax, Ontario, Canada

    Xypex products were used to waterproof and protect the concrete of this reservoir.

    Read More

  • Al Khalifa Port and Industrial Zone

    Dubai, United Arab Emirates

    Xypex was used in the construction of this 20 million TEU port to waterproof the pile heads, using Xypex Concentrate material.

    Read More

  • Alcala De Henares Development

    Madrid, Spain

    The Xypex repairs were made from the inside against extreme hydrostatic pressure and were completely successful.

    Read More

  • Alegria Wastewater Treatment Plant

    Rio de Janeiro, Brazil

    Processing wastewater for Rio de Janeiro, a city of more than 11 million people, is a persistent economic and engineering challenge. But Rio thinks big, and in seven mammoth plants around Guanamara Bay, the Brazilian city is tackling the challenge of wastewater volume and ecological responsibility.

    Read More

  • Alem International Building

    Addis Abeba, Ethiopia

    The base foundation slab and the joints at the wall / slab interface were waterproofed with Xypex Concentrate.

    Read More

  • Alesund Boligbyggelag – Parking Structure

    Alesund, Norway

    This large car parking structure of 4,000 square meters was completely treated with Xypex waterproofing materials.

    Read More

  • All Seasons Place

    Bangkok, Thailand

    Xypex products were used on foundation walls, slabs, water and STP tanks throughout phase 4 of this hotel and office complex.

    Read More

  • Almaktaba Super Store

    Jeddah, Saudi Arabia

    Persistent flooding occurred on the below-ground-floor level of this supermarket, causing severe chloride/sulphate attack. 

    Read More

  • Almond Bay House

    Barbados

    Xypex Patch'n Plug and Xypex Concentrate were used to seal off several purpose-built pressure release holes in the below-grade swimming pool of this structure.

    Read More

  • Alyeska Pipeline Water Treatment Facility

    Valdez, Alaska, USA

    The ballast water from the super-tankers that take on oil at Valdez is treated at this site. Xypex Concentrate was applied to the two final water purifying tanks. After final purification, the water is pumped back into the ocean. This process is part of Alyeska’s commitment to preserving the ecology in this marine environment.

    Read More

  • Amagi Kogen Ice Skating Rink

    Shizuoka, Japan

    The Xypex crystalline system was applied to this newly poured concrete slab using the 'dry-shake' method. After spreading the Xypex Concentrate powder evenly over the concrete surface, the application was finished by power trowelling the material into the top surface area of the concrete.

    Read More

  • Amata Industrial Park – Tower Tank

    Bien Hoa, Dong Nai, Vietnam

    Xypex was selected by Bechtel to waterproof a tower tank 27 m above the ground. Defective concrete was chipped out and repaired with Xypex Concentrate followed by the application of a 2:1 cement mortar patching compound. Xypex Concentrate and Modified were then applied over the repaired concrete.

    Read More

  • Amata Industrial Park – Water Supply Plant

    Bien Hoa, Dong Nai, Vietnam

    Xypex provided both the material and technical guidance to repair and waterproof the subterranean construction joints of these two 2,500 m2 water tanks where high hydrostatic pressure was causing leakage. Approximately 160 linear meters of construction joints were repaired and waterproofed.

    Read More

  • Amathus Beach Hotel

    Cyprus

    This swimming pool was waterproofed with Xypex during construction. The pool is successfully used throughout the year.

    Read More

  • Ampera Townhouses

    Jakarta, Indonesia

    A two-coat application of Xypex Concentrate and Modified was used to waterproof the roof deck and ground-water reservoir. Xypex Dry-Pac was applied to the construction joints and Xypex Concentrate was used to waterproof all bathrooms.

    Read More

  • Ankara Subway Tunnels

    Turkey

    11,000 linear meters of cracks were repaired with Xypex Patch'n Plug to stop water ingress through the construction joints of this tunnel. A surface area of 5,600 m2 was waterproofed with Xypex Concentrate and Modified.

    Read More

  • Antel 2000 Corporate Centre

    Makati City, Philippines

    Xypex products were applied to the concrete in a number of areas throughout this structure, including the cooling tower, roof deck, kitchen, canopy, elevator pit, cistern tank, helipad, parking area, roof, tank deck and planter box.

    Read More

  • Antel Seaview Towers

    Pasay, Philippines

    Xypex products were used to waterproof and protect the concrete in a number of areas in this structure, including the cistern tank, parking area, vehicle ramp, swimming pool and deck, laundry, kitchen, planters, terrace, canopy, helipad, tank and roof deck, basement walls, air-conditioning unit and box, aeration tank, covered walk and balcony.

    Read More

  • Aomori Bay Bridge

    Aomori, Japan

    The Aomori Bay Bridge, measuring 25 m in width and 1,219 m in length, is exposed to salt from the ocean causing damage to the pre-cast concrete girder box main beams. Xypex was applied to the bottom plate of the main girder from the inside of the girder box and to the upper surface of the bottom plates. The result is a permanently waterproofed structure that is impervious to the elements.

    Read More

  • Aomori Wastewater Treatment Tunnel

    Aomori, Japan

    Xypex Ultra Plug was used to prevent water leakage from the cracks and construction joints of the original box culvert tunnel. Xypex Concentrate was then applied to the entire surface. To reinforce the ‘box’, a U shaped concrete lining, using Xypex Admix C-2000 was then installed.

    Read More

  • Apartment Building

    Abu Dubai, United Arab Emirates

    All decks, kitchens and bathrooms were waterproofed and protected with Xypex products.

    Read More

  • Apartment Building – Maipu 1070

    Buenos Aires, Argentina

    The total structure was treated with Xypex Modified. The pump and reservoir tanks were treated with Xypex Concentrate and the swimming pool was waterproofed with Xypex Admix C-2000.

    Read More

  • Aqua Park

    Kuwait

    Xypex waterproofing products were used extensively in the construction of this new Aqua Park.

    Read More

  • Aquaduct – Lago Muster, Comodor Rivadavia

    Chubut-Santa Cruz, Argentina

    Xypex Patch'n Plug was used to repair construction joints while Xypex Concentrate was used to waterproof all the surfaces.

    Read More

  • Archangelsk Stadium

    Archangelsk, Russia

    Approximately 2,000 kg of Xypex Concentrate was applied to the surface of the stadium stands to prevent water penetration into the rooms below.

    Read More

  • Archive Storage Rooms

    Tel Aviv, Israel

    Located 3 floors below ground level, the storage rooms containing valuable archives was subjected to considerable water leakage and exhibited the effects of the dampness and there was clear evidence of mold on the files.

    Read More

  • Ariake South District Model Building

    Tokyo, Japan

    Xypex Patch'n Plug was used to seal the joints and cracks in the basement, followed by a two-coat treatment with Xypex Concentrate and Modified.

    Read More

  • Asian Development Bank Headquarters

    Manila, Philippines

    The new headquarters building for the Asian Development Bank was constructed in Manila by Hyundai Engineering & Construction Co. Ltd. The Xypex crystalline system was used to waterproof basement areas, a large potable water tank and a roof deck. The total area treated was approx. 9,300 m2 (100,000 sq. ft.).

    Read More

  • Aspinwall Water Filtration Plant

    Pittsburgh, Pennsylvania, USA

    Seventeen large water filtration tanks with a total surface area of 11,150 m2 (120,000 sq. ft.), were treated with Xypex products. Not only did the Xypex products provide an effective waterproofing system for these concrete structures, but they also provided protection from the effects of potentially harmful chemicals.

    Read More

  • Athenee Rehabilitation

    Bucharest, Romania

    This 40 year old sump pit in downtown Bucharest was successfully repaired with Xypex products, including Xypex Patch'n Plug and Xypex Modified.

    Read More

  • Atochem Sodium Chlorate Tank

    Isere, France

    This concrete tank at the Isere Atochem plant was deteriorating due to the aggressive action of NaClO3. Xypex was used to eliminate leakage and to protect the concrete structure from further damage. 

    Read More

  • Atrium Business Centre

    Warsaw, Poland

    Xypex Patch'n Plug was used to repair cracks. Xypex Concentrate and Modified were then applied to the walls and floor to waterproof the area.

    Read More

  • Auburn Swimming Pool

    Auburn, Alabama, USA

    A two-coat application of Xypex Concentrate and Modified was spray-applied to the 40,000 sq. ft. concrete surface of this University swimming pool. The Xypex coating was subsequently sandblasted off two months later. The pool was then filled. Hydrostatic pressure-testing confirmed that the Xypex crystalline process had successfully penetrated the concrete and no water seepage was evident.

    Read More

  • Auckland Parking Structure

    Auckland, New Zealand

    Xypex Concentrate was used to waterproof the parking decks, parkades and walkways of this waterfront facility.

    Read More

  • Australian Marine Complex

    Perth, Australia

    The Australian Marine Complex (AMC) is a world-class centre for excellence for manufacturing, fabrication, assembly, maintenance and technology servicing the marine, defence, oil and gas, and resource industry.

    Read More

  • Ayrton Senna Tunnel Complex

    São Paulo, Brazil

    This tunnel passes under the lagoon in Ibirapuera park. A two-coat shotcrete application of Xypex Concentrate was applied to 2,800 meters of concrete, in two separate tubes within the tunnel. Xypex Patch'n Plug was used to seal the cracks with water seepage.

    Read More

  • B.C. Place Stadium

    Vancouver, British Columbia, Canada

    Xypex products were used to waterproof the deck of the plaza area which forms the main pedestrian access to the stadium. Below the plaza deck are several levels of car parking. A decorative topping was subsequently applied over the Xypex treatment.

    Read More

  • Bahir Dar Air Force Camp

    Bahir Dar, Ethiopia

    A two-coat application of Xypex Concentrate and Modified was used to repair and waterproof the interior surface of the swimming pool, water reservoirs, and six chamber septic tanks. Patch'n Plug was used to repair the poor quality concrete that was full of voids and honeycombing. A total of 3,940 kg of Xypex Concentrate, 2,350 kg of Xypex Modified and 1,330 kg of Xypex Patch'n Plug was utilized.

    Read More

  • Baldwin Water Treatment Plant

    Cleveland, Ohio, USA

    Xypex products were specified by the Cleveland Dept. of Public Utilities for use on a major filter rehabilitation project covering the Baldwin, Division and Crown Water Treatment Plants located in the City of Cleveland. 

    Read More

  • Bank of China

    Beijing, China

    The foundation of the bank is 18 - 20 metres below ground level and the underground water level is 5-6 metres below ground level. 600 pails of Xypex Concentrate and Modified were used to waterproof this challenging underground part of the structure.

    Read More

  • Bank of Tanzania

    Tanzania

    Five large money-storing vaults were the focus of this Xypex project. The below grade foundation is subjected to eight meters of head pressure. Because of this situation, two coats of Xypex were applied to the exterior of the vault walls and floor slab.

    Read More

  • Bank Vitalicio

    Spain

    Xypex Concentrate was used to completely waterproof the slab and the column piths. The joints of the slab were treated with Xypex between pours.

    Read More

  • Baramante Piazza Building

    Manila, Philippines

    Xypex Patch'n Plug and Xypex Concentrate were used to repair and waterproof tie-holes and the concrete slab.

    Read More

  • Barbados Aquarium

    Barbados

    The construction of the first commercial sea-water aquarium in the Barbados was started in June, 2004. Xypex Admix C-1000 was used in all structures holding sea water as well as in the pump rooms and electrical stations.

    Read More

  • Barbados Hilton

    Bridgetown, Barbados

    Xypex Admix was blended into the concrete mix and used to waterproof and protect the swimming pools, sewage clarification tanks and basements of this new hotel.

    Read More

  • Bay City Memorial Stadium

    Bay City,

    The entire floor slabs in the bleacher seating area were treated with the Xypex system to eliminate water seepage into the locker rooms below and to prevent deterioration of the concrete.

    Read More

  • BBG-Systemcellar

    Austria

    Xypex Admix C-1000 NF and Xypex Concentrate were specified for use in the production of 40 such cellars in 2004. In 2005, over 100 BBG-Systemcellars of various private homes throughout Austria will be built using Xypex Crystalline Technology to prevent the ingress of groundwater.

    Read More

  • Bearspaw Water Treatment Facility

    Calgary, Alberta, Canada

    Xypex products were used extensively to waterproof and protect the concrete of this water treatment facility: 500 - 50 lb. bags of Xypex Concentrate; 500 - 50 lb. bags of Xypex Modified; 150 - 60 lb. pails of Xypex Dryshake DS-1; and 50 - 60 lb. pails of Xypex Patch'n Plug.

    Read More

  • Bedaling Expressway Overpasses

    Beijing, China

    The Bedaling Expressway, which includes three overpasses, leads to the world famous Great Wall of China. The surfaces of these overpasses were waterproofed using Xypex Concentrate and Xypex Patch'n Plug repaired the cracks. Bridge experts lauded the success of the Xypex application.

    Read More

  • Beijing Capital Airport

    Beijing, China

    The second floor platform of the new station at the Beijing airport was waterproofed with Xypex materials.

    Read More

  • Beijing Olympics Stadium

    Beijing, China

    Waterproofing materials used in this landmark project, site of the opening and closing ceremonies at this year's summer Olympics, were required to meet high environmental standards, have good corrosion resistance, durability, permeability and to be non-toxic.

    Read More

  • Belcarra Park Water Reservoir

    Belcarra, British Columbia, Canada

    This 60,000 gallon water reservoir was waterproofed with Xypex products. Xypex Dry-Pac was used on 400 lineal feet followed by a two-coat spray application of Xypex Concentrate and Modified.

    Read More

  • Belmont Water Treatment Plant

    Philadelphia, Pennsylvania, USA

    To better fit the construction schedule, Xypex was used instead of a membrane. Xypex Admix C-1000 was used to waterproof the walls and Xypex Concentrate DS-1 to waterproof the floors.

    Read More

  • Benelong Point

    Sydney, Australia

    Xypex Admix was used throughout this project to waterproof and protect the concrete walls and slabs.

    Read More

  • Benziger Family Winery

    Napa Valley, California, USA

    Xypex Admix, with a colored pigment, was used to stop water penetration into the underground tunnels and wine-storage caves. Xypex Patch’n Plug was used to repair larger cracks.

    Read More

  • Beograd Parking Structure

    Belgrade, Serbia & Montenegro

    This below-ground parking structure was waterproofed with a two-coat application of Xypex Concentrate and Modified. Xypex Dryshake was applied to the base slab of this parking structure which is located 12 m below ground level.

    Read More

  • Biggar Reservoir

    Biggar, Saskatchewan, Canada

    Xypex Admix C-1000 was blended into the mix to waterproof and protect the concrete in this reservoir.

    Read More

  • Biological Water-Purifying Reservoir

    Novgorod, Russia

    Up to 7685 kg of Xypex Patch'n Plug was used to repair and seal 1100 m of joints between concrete blocks. Xypex Concentrate and Modified were then used to waterproof over 7080 m2 of surface area.

    Read More

  • Bkae “Salthouse” Cellar

    Budapest, Hungary

    This 19th Century money exchange bank, built on the shores of the river Danube, consists of a large cellar system that connects the “Salthouse” with the “Main Duty House”. The cellars access the river through 4 lock gates. Xypex products were used to waterproof and protect the cellar concrete.

    Read More

  • BOC Gases Headquarters

    North Ryde, Austria

    Xypex Admix NF was blended with 600 m3 of concrete to waterproof and protect the roof deck of this building.

    Read More

  • Bogong Power Station

    Bogong, Australia

    Xypex Admix C-Series was specified for use in 12,000 m³ of concrete for this new power station development, designed to provide an additional 140 MW to the Kiewa hydroelectric scheme. The Xypex system was used to enhance long-term durability and provide added waterproofing integrity for this vital infrastructure development.

    Read More

  • Bogotá Wastewater Treatment Plant

    Bogotá, Colombia

    This is the first of three Bogotá wastewater treatment plants to be treated with Xypex products. Xypex Patch'n Plug was used to repair defects and stop water leakage in the concrete before application of the coating system. More than 5,000 kg of Xypex products was used in the concrete waterproofing process.

    Read More

  • Boston CSO Project

    Boston, Massachusetts, USA

    As part of its two-year program to upgrade the city’s sewers, drains and pipes, the Boston Water and Sewer Commission approved the use of Xypex Admix C-500 as the concrete waterproofing and protection ingredient in the pre-cast culvert boxes of the new combined sewer overflow system (CSO) at Dorchester Morrissey Boulevard in downtown Boston.

    Read More

  • Breclav Savings Bank

    Breclav, Czech Republic

    When the membrane waterproofing system of this new savings bank building failed, the four elevator shafts had to be rehabilitated and waterproofed with Xypex Patch'n Plug and Xypex Concentrate.

    Read More

  • Bremerton Tunnel

    Bremerton, Washington, USA

    Traditional waterproofing membrane systems were deemed unsuitable by Brenden Clarke, on-site project engineer for the Washington State Department of Transportation (WSDOT).

    Read More

  • Bresnik Private Swimming Pool

    Bulgaria

    A two coat application of Xypex Concentrate and Xypex Modified were used to waterproof this newly built pool. The joints were treated according to the specification.

    Read More

  • Breznik Private Swimming Pool

    Breznik, Bulgaria

    A two-coat application of Xypex Concentrate and Xypex Modified were used to waterproof this newly built pool. The joints were treated according to the specification.

    Read More

  • Bridge Deck Repairs

    La Crosse, Wisconsin, USA

    Xypex products were used to repair this bridge deck which is under authority of the State of Wisconsin Department of Transportation. Repairs included the routing out and dry-packing of 92 metres (300 lin. ft.) of crack, and a one coat application of Xypex Concentrate over the entire surface. 

    Read More

  • Bridge Overpass

    Zilina, Slovakia

    During the construction of a by-pass road around Zilina, Xypex was proposed and implemented to protect the concrete parapet against the aggressive effects of salt used on icy roads. The parapets were treated on both sides of the bridge – a total of 1,500 m.

    Read More

  • Bridge Parapet

    Czech Republic

    Xypex Concentrate was used to protect the concrete parapet of this bridge against water penetration and against the destructive effects of the salt used in the winter months.

    Read More

  • Brisa Tire Plant

    Izmit, Turkey

    Minor earthquake damage to the concrete was repaired with Xypex products. Xypex Concentrate and Modified were then used to waterproof the two foundations on which the tire-pressing machinery would be placed.

    Read More

  • Broadcast Hill Feeder Main

    Banff, Alberta, Canada

    The joints of this 900 mm diameter concrete water pipe were welded every 36 ft. and then filled with Xypex Megamix II.

    Read More

  • Bronx Zoo

    Bronx, New York, USA

    Jolly Miller Construction used 3360 lbs. of Xypex Admix C-1000 in their shotcrete mix for the water holding structures of the Primate Exhibit in this zoo. This exhibit won an award in 2000 from the American Zoo and Aquarium Association. The total area of the exhibit covers 6.5 acres.

    Read More

  • Buenos Aires Water Reservoir

    Buenos Aires, Argentina

    The contractor had serious problems with the concrete in this reservoir structure. Xypex was used to remedy the water seepage problems in the concrete.

    Read More

  • Bund Sightseeing Tunnel

    Shanghai, China

    The Bund sightseeing tunnel, which is open to traffic, passes under the Huangpu River. The tunnel is located beneath the television tower in the Pudong Development District. Xypex products were used to waterproof this tunnel.

    Read More

  • Busselton Jetty

    Busselton, Australia

    Xypex Admix C-5000 was specified for all concrete used in the refurbishment as protection of concrete used in a marine environment.

    Read More

  • Cala Homes – Weybridge

    USA

    A total of 5,700 kg of Admix C-1000 was added to the concrete required for 1,400 m3 of this parking structure. 1,500 kg of Xypex Concentrate was applied to the joints.

    Read More

  • Calistoga Wastewater Treatment Plant

    Calistoga, California, USA

    A two-coat treatment of Xypex Concentrate and Modified was used to waterproof and protect the digester tanks as part of the upgrading of this wastewater treatment plant.

    Read More

  • Cal-Piers Headquarters

    Sacramento, California, USA

    A two-coat treatment of Xypex Concentrate and Modified was used to waterproof and protect the 1,700 piers and footings of this headquarters building.

    Read More

  • Camurugipe Sewage Pipeline

    Salvador, Bahia, Brazil

    This pipeline, with a diameter of 2.40 m, exhibited serious leakage through various joints. Over 13,000 kg of Xypex Patch'n Plug and Xypex Concentrate was applied.

    Read More

  • Canadian Crude Separators

    Edson, Alberta, Canada

    Xypex Admix C-1000 was used to waterproof and protect the tank slabs and walls of this containment structure for the reclamation of soils. A total of 26,000 lbs. of Xypex Admix was utilized for 1,000 m3 of concrete.

    Read More

  • Canadian Embassy

    Berne, Switzerland

    Xypex products were used to waterproof and protect the basement walls and floor of the embassy.

    Read More

  • Canóvanas Filtration Plant

    Canóvanas, Catalonia, Puerto Rico

    The thickening tank (92 ft. diameter by 15 ft. deep) of this filtration plant used Xypex Patch'n Plug to repair structural defects followed by a coating of Xypex Concentrate. Upon review, the Xypex treatment proved to be very successful, rendering the tank impenetrable by water.

    Read More

  • Capital Library

    Beijing, China

    The storage room for rare books and the underground equipment room of this Library building were waterproofed and protected with a two-coat application of Xypex Concentrate and Modified.

    Read More

  • Cardedeu Water Purifying Plant

    Barcelona, Spain

    The Cardedeu water purifying plant supplies Barcelona and other towns with drinking water. The filter channels to this Water Purifying Plant were repaired and waterproofed with Xypex products.

    Read More

  • Casa De Campo Complex

    Casa de Campo, Dominican Republic

    Xypex Concentrate and Modified were used to waterproof the basement walls, exterior terraces, and a private pool at this exclusive tourist destination. The complex consists of 116 villas, an artificial lake and four championship golf courses.

    Read More

  • Casa Lapostolle Winery

    Valle de Colchagua, Chile

    Xypex Concentrate was applied to the exterior surfaces of this tank which is used to store the waste liquids from wine production. Xypex Patch'n Plug was used to repair cracks.

    Read More

  • Cathedral of Christ the Saviour

    Moscow, Russia

    Xypex products were used throughout this beautiful Cathedral to waterproof and protect the concrete.

    Read More

  • Central Bank Building

    Colombo, Sri Lanka

    Xypex products were used to waterproof al exterior foundation walls of this bank. Xypex was also used to repair various honeycombed areas before the brush application.

    Read More

  • Central Reservoir

    Bezanija, Serbia & Montenegro

    This old concrete structure, built in the 1950s, developed serious leakage problems in a number of different places. 345 m of crack repairs and 300 m2 of surface area were successfully performed from the negative side using Xypex products.

    Read More

  • Centro Hotel, Sharjah Airport

    Dubai, United Arab Emirates

    Following extensive worldwide use of Xypex in this application, it was decided to use Xypex Admix C-1000 as a more efficient alternative for the ready-mix concrete, together with Xypex Concentrate for joints and tie-holes. After successful flooding-tests, Xypex was then specified and successfully used in water tanks and reservoirs.

    Read More

  • Cerveceria Costa Rica

    San José, Costa Rica

    Xypex Concentrate was used to waterproof and protect the water reservoirs of this brewery – the largest in Costa Rica.

    Read More

  • Ceske Velenice Gas Station

    Czech Republic

    Xypex Concentrate and Modified were spray-applied to this tank as additional insulation and to prevent chemical seepage into the surrounding ground.

    Read More

  • Chaira Hydro Power Plant

    Chaira, Bulgaria

    The concrete located 350 meters under the surface of this electric power plant had cracked and was leaking. Xypex Patch'n Plug and Xypex Concentrate were used on a gradual basis until all the leaks were stopped.

    Read More

  • Chantier Pool

    Dully, Switzerland

    Xypex products were used in the restoration and waterproofing of this pool at a unique estate in Switzerland.

    Read More

  • Charles De Gaulle Plaza Office Building

    Bucharest, Romania

    This building has 5 basement floors; most are for parking but the utilities are housed here as well (the fire water tank stretches along the 3 bottom floors). 

    Read More

  • Church Roof

    Toluca, Mexico

    Xypex Concentrate and Modified were used to waterproof the roof of this beautifully designed church. The application was performed by personnel of the local Xypex dealer for the Toluca area.

    Read More

  • Citibank Tower

    Makati City, Philippines

    Citibank is the largest commercial bank in the Philippines. Xypex products were used to waterproof the basement walls, overhead water tank, the canopy and the underground water tank of this bank building.

    Read More

  • Citigroup Headquarters Building

    Sydney, Australia

    Xypex Admix C-1000 NF and Admix C-2000 NF were used in the 90 MPa concrete. Xypex Concentrate DS-1 was applied to concrete 150 m above street level.

    Read More

  • City Fountain

    Panevezis, Lithuania

    A two-coat application of Xypex Concentrate and Modified was applied to all the concrete surfaces of this City Fountain. Because the application took place in cold weather, the fountain was covered and heated to protect the Xypex treatment.

    Read More

  • City Hall Underground Railway Station

    Warsaw, Poland

    This was the first underground railway station in Poland to be waterproofed using Xypex products. The foundation plates, slab, walls and construction joints of the main tunnel and four of the exit tunnels were waterproofed.

    Read More

  • City of Langley Fresh Water Reservoir

    Langley, British Columbia, Canada

    This 16 million gallon reservoir was extensively waterproofed using Xypex products. Xypex Dryshake DS-1 was used on the floors, and all cracks and tie holes were treated with the Xypex system. Xypex Concentrate and Modified were used to waterproof the walls.

    Read More

  • City of Nelson Sewage Plant Addition

    Nelson, British Columbia, Canada

    Xypex Admix C-1000 was blended into the concrete mix to waterproof and protect the walls and slab of this sewage plant extension. Xypex Megamix II was used to patch the tie holes.

    Read More

  • Clareview Reservoir

    Edmonton, Alberta, Canada

    A coat of Xypex Concentrate followed by a coat of Xypex Modified were applied to interior walls and slabs of this 62.5 million litre (16.5 million gallon) reservoir. Total area treated was 16,000 m2 (172,000 sq ft). In addition, 135 support columns were treated with the Xypex system to prevent corrosion of the reinforcing steel.

    Read More

  • Club Aquaria Water Park And Resort

    Mumbai, India

    Below-grade ground water was seeping through construction joints into the Lazy River and Wave Pool. Xypex products were successfully applied to the siphonic duct portion of the structure and to the trenches in the basement to stop the leaks and waterproof the concrete.

    Read More

  • Club Himalaya Resort Hotel

    Nagarkot Hill, Nepal

    Xypex Concentrate and Dry-Pac were used extensively to waterproof and protect the concrete of this Hotel. Xypex was applied to foundation floors, roofs, terraces, elevator pits, sunken slabs, manholes, hot water indoor swimming pool, and both underground and above ground drinking water reservoir tanks.

    Read More

  • Coca Cola Bottling Plant

    Istanbul, Turkey

    The foundation of this bottling and distribution plant was waterproofed with Xypex Concentrate and Modified.

    Read More

  • Colibita Dam – Gatehouse

    Romania

    Xypex products were used to waterproof and protect numerous areas on this Dam’s Gatehouse.

    Read More

  • Colinas Mall

    Santiago, Dominican Republic

    Xypex Admix, Concentrate and DS-1 were used in the final phase of construction of this mall, including the exterior parking lot.

    Read More

  • Commercial Bank of Ethiopia

    Bahr Dar, Ethiopia

    A two-coat application of Xypex Concentrate and Modified was applied as a slurry coating to waterproof roof slabs, balconies, underground concrete water-reservoir and pump house. Xypex Patch'n Plug was used to repair and waterproof cracks.

    Read More

  • Comodoro Rivadavia Aquaduct

    Chubut, Argentina

    Xypex’s unique crystalline technology was used to waterproof and protect tanks and pump stations of this 223 km aqueduct. Installation included repair of all defects, construction joints and tie holes with Xypex Patch’n Plug, followed by a two-coat application of Xypex Concentrate and Modified.

    Read More

  • Conrad Maldives Resort & Spa

    Maldives, New Zealand

    Two Sunset Water Villa Pools, nestled within a tidal coral reef, were built for the Conrad Maldives Resort and Spa on Rangali Island in the Maldives. 

    Read More

  • Cooling Tank

    Slovakia

    The cooling tank under the ventilator cooling towers was originally coated with an epoxy which did not weather well and had become non-functional after 6 years. The worn epoxy surface was removed and a slurry coat of Xypex Concentrate was applied. Damaged areas were repaired with cement dosed with Xypex Admix cement, the pool surface was treated with Xypex Modified, and the cracks and joints sealed with Xypex Dry-Pac.

    Read More

  • Cooperativa Dos Pinos

    San José, Costa Rica

    Xypex Concentrate was used to waterproof the water reservoirs of this dairy products company – the largest producer in Costa Rica.

    Read More

  • Copenhagen Metro

    Copenhagen, Denmark

    Xypex was used to seal fine cracks in the entranceway panels, station walls, manholes, ramps and station roof. Xypex Concentrate Grey was mixed with 1.5% black oxide to provide a uniform color. All leakage was stopped even under more than 6 m head of water pressure. Xypex products were also used to repair cracks in the concrete at the new Central Station.

    Read More

  • Copia Center for Wine, Food and The Arts

    Napa Valley, California, USA

    Xypex Admix was used to waterproof the water feature of the channel. Xypex Concentrate and Patch'n Plug were used to seal leaks.

    Read More

  • Cornwall Aquatic Centre

    Cornwall, Ontario, Canada

    Xypex products were used to waterproof and protect the walls and slab of this swimming pool.

    Read More

  • Cosmo Centro

    Cali, Colombia

    All the floors of this new parking lot and its outlet facilities were waterproofed with Xypex Admix.

    Read More

  • Cov Bratislava Petrzalka-Utesnenie Kopule

    Bratislava, Slovakia

    To prevent gas leakage, Xypex FCM was applied to the roof of this reservoir structure. Xypex Patch'n Plug and Xypex Concentrate were also used to repair cracks.

    Read More

  • Craft Paper Plant

    Manila, Philippines

    Xypex Crystalline Technology was selected as the solution to the leaking problems in the concrete silos of this craft paper plant.

    Read More

  • Creaton Tiled Roof Factory

    Lenti, Hungary

    Xypex Concentrate was applied as a slurry coat to the walls of an underground tunnel in this building – an area subject to high hydrostatic pressure. Xypex Patch’n Plug was used to seal cracks and other defects in the tunnel walls. A total area of 1,000 m2 was treated with Xypex products.

    Read More

  • Cronulla Marina

    Sydney, Australia

    Dosed at 4 kg/m3 with Xypex Admix C-2000 NF, this mix was designed to achieve 32 MPa at 48 hours and 50 MPa in seven days. The two-tonne post-tensioned units of this floating concrete structure had to be lifted from their formwork 36 - 48 hours after casting.

    Read More

  • Crossroads Mall

    Mumbai, India

    Xypex products were used to repair and waterproof 4,500 linear feet of leaking concrete cracks where jets of water, due to high hydrostatic pressure, were occurring. Terraces, water tanks, car lift pits, and toilets were also waterproofed with Xypex.

    Read More

  • Crotty Dam Dewatering Outlet Shaft

    Queenstown, Australia

    The Xypex waterproofing system was specified by the Hydro Electricity Commission of Tasmania for use in this deep concrete shaft which comprises part of the King River Power Development Scheme.

    Read More

  • D4 – Potable Water Reservoir

    Dundalk, Ontario, Canada

    The concrete of this 50,000 gallon potable water reservoir with walls measuring 300 - 450 mm thick, was treated with Xypex Concentrate and Modified to provide waterproofing and protection.

    Read More

  • Daewoo Building

    Warsaw, Poland

    Xypex Concentrate was used to waterproof the foundation walls and slab of the Daewoo Building.

    Read More

  • Daisin Vietnam Factory

    Bien Hoa, Dong Nai, Vietnam

    Xypex was selected to waterproof the waste and water treatment plants, grease traps, and waste pits by Obayashi Corporation, the main contractor. 

    Read More

  • Dau Tieng Dam

    Tay Ninh, Vietnam

    After a successful trial in 1997, Xypex was specified and used to waterproof 400 m2 of the upstream discharge chamber of this dam. Xypex also supplied on-site technical support.

    Read More

  • Dee Why Seawall

    Dee Why, Australia

    Xypex Admix was used in the mix design to help achieve greater concrete durability. Durability was one of the most important objectives in the design of this seawall. Aesthetics were also a prime objective and a beige oxide was added to the Xypex Admix used in all visible areas.

    Read More

  • Deichtorhallen

    Hamburg, Germany

    Because of the proximity of the buildings to the seaside, humidity and water penetration became a problem in this over 100 year old structure. Water was penetrating through the foundation slab and through cracks in the wall to such a degree that cracks formed in the interior zone.

    Read More

  • Dewan Perdana Feldar – Jalan Maktab

    Kuala Lumpur, Malaysia

    The site, which has a very high water table, required 7,619 m3 of Xypex Admix C-2000 NF to waterproof and protect the thick basement slab and the retaining walls of two underground car parks.

    Read More

  • DHL Headquarters

    Mumbai, India

    850 linear ft. were routed out and repaired with Xypex Patch'n Plug. A coat of Xypex Concentrate was then applied over the entire surface.

    Read More

  • Diamond Plaza – International Business Center

    Ho Chi Minh City, Vietnam

    Xypex products were used to repair and waterproof a wide variety of places within this 22 story building, including: screen wall coves along diaphragm walls; septic tank; 3 water tanks; 2 elevator pits; one electrical vault; machine room slab; bathrooms and laundry rooms.

    Read More

  • Dix-Sept Reservoir

    Natel, Brazil

    Xypex Concentrate and Modified were applied to the interior of this reservoir to waterproof and protect the concrete.

    Read More

  • Domas Condominiums

    Vancouver, British Columbia, Canada

    Xypex Concentrate was used to waterproof all construction joints.

    Read More

  • Drainage Overflow Pipe

    Moscow, Russia

    The 3 cm joints of this overflow pipe were left open during construction. All these joints were treated with Xypex Concentrate then filled with Xypex Patch'n Plug to ensure watertightness. Subsequent hydraulic testing indicated no leakages.

    Read More

  • Drinking Water Reservoirs

    Parandak, Iran

    Over 11,300 kg (25,000 lbs) of Xypex Concentrate were applied to these two reservoirs being built at Parandak for the Ministry of Urban Housing. 

    Read More

  • Dubai Metro

    Dubai, United Arab Emirates

    Following deterioration of the concrete in and around the channels drains, it was decided to give further protection through the application of Xypex Concentrate along 3.5 km of the Red and Green Lines.

    Read More

  • Dupen Fountain Pool – Seattle Center

    Seattle, Washington, USA

    Persistent ground water intrusion through the various coatings on this 1962 pool caused the coatings to delaminate. Prior to a new decorative pool coating, Xypex Concentrate was applied to the surface. Xypex Gamma Cure was used to speed Xypex crystalline development. Xypex Megamix with Xypex Xycrylic Admix was brushed over the surface within 24 hours.

    Read More

  • Duracell Battery Warehouse

    Cleveland, Tennessee, USA

    Xypex Dryshake was applied to the floor of the distribution warehouse to prevent water permeating up through the slab. Xypex DS-2 was used to improve the resistance of the concrete surface to heavy forklift traffic.

    Read More

  • E1 (North) & E3 (South) Potable Water Reservoirs

    Elora, Ontario, Canada

    This 50,000 gallon potable water reservoir was waterproofed and protected with Xypex Concentrate and Modified.

    Read More

  • El Faro Aquarium

    Mar Del Plata, Argentina

    The Xypex crystalline system was used on the first of several phases planned for this aquarium project at Mar del Plata, a resort city southeast of Buenos Aires. When completed, the aquarium will be the second largest in Argentina. 

    Read More

  • El Penon Mine

    Northern Chile, Chile

    Xypex products were used to repair and waterproof the concrete slab under the process silos. The Xypex treatment prevented the contamination of ground water.

    Read More

  • Empresa De Acueducto De Bogota

    Bogotá, Colombia

    Xypex was specified as the preferred technology for the waterproofing and repair of this potable water tank. Xypex will be used to waterproof an additional 20 such tanks all of which are at least 20 years old.

    Read More

  • Enerjisa Power Generating Station

    Izmit, Turkey

    An earthquake had damaged areas of this power plant and Xypex was used to repair it. Xypex Concentrate, Modified and Patch'n Plug were used to waterproof the gallery curtain walls, the ceilings and the floor slabs.

    Read More

  • Engativa Hospital Heliport

    Bogotá, Colombia

    Xypex Admix was used in the 400 m2 topping for the Heliport at this hospital. The structural slab underneath was repaired and waterproofed with Xypex Patch'n Plug and Concentrate prior to placing the topping.

    Read More

  • Entes Palmirova Hotel Swimming Pool

    Antalya, Turkey

    Walls and floor area of this swimming pool at the Entes Palmirova Hotel in Antalya, were waterproofed with a two coat application of Xypex Concentrate and Modified. The total area treated was approximately 1,210 m2 (13,000 sq. ft.).

    Read More

  • Erdington Water Reservoir

    Birmingham, United Kingdom

    A total of 580 columns were treated with Xypex Concentrate and Xypex Modified at this 60 year old potable water reservoir near Birmingham. Each column has a surface area of 12 square metres (129 sq. ft.). 

    Read More

  • Esplanade Theatres on The Bay

    Singapore

    Xypex Admix C-Series was dosed in the entire base slab under the theatres at the Esplanade Theatres On The Bay (Phase 2) project.

    Read More

  • Essel Water Reservoir

    Rancagua, Chile

    The cracked concrete and rock pockets around the expansion joints of this 40,000 m3water tank were repaired with Xypex Patch'n Plug followed by an application of Xypex Concentrate.

    Read More

  • Faculty of Medicine

    Argentina

    The spalling of the parge coat surface was repaired using Xypex Concentrate as the bonding layer, and to protect the reinforcing steel.

    Read More

  • Fany Sham Dam

    Hsintien, Taiwan

    Xypex Concentrate, Modified and Patch'n Plug were used to repair water seepage through joints in the walls of this dam. The application eliminated all seepage and prevented oxidation of the steel reinforcement. The dam is operated by the Water Conservation Bureau and the reservoir supplies water for the City of Taipei.

    Read More

  • Federal Express Headquarters

    Memphis, USA

    Areas of application included all exposed slabs, below grade walls, and a large underground air conditioning vault. Total area treated was approximately 7,000 m2 (75,300 sq. ft.).

    Read More

  • Federal Police Headquarters

    Addis Abeba, Ethiopia

    The dome roof, balconies, and roof gutters were treated with a two-coat application of Xypex Concentrate and Modified. Cracks and construction joints were routed outs, coated with a slurry of Concentrate and packed with Xypex Patch'n Plug. All surfaces were scabbled by hand to provide a rough texture to promote the proper bond of the Xypex coatings.

    Read More

  • Ferrari World Abu Dhabi

    Dubai, United Arab Emirates

    Following the identification of severe cracking in the lower deck of the Welcome Hotel Pavilion Water Feature, Xypex Patch'n Plug and Xypex Concentrate were used to repair the cracks and provide waterproofing to the body of concrete, thus avoiding expensive re-working.

    Read More

  • Finansbank Operations Center

    Istanbul, Turkey

    The Xypex concrete waterproofing system was specified after the failure of another waterproofing material. The failed material was water-blasted off the concrete surface and Xypex Concentrate, Modified and Patch'n Plug were then applied.

    Read More

  • Fisherman’s Wharf

    Macau

    Xypex products were used to waterproof and protect the foundations of Macau’s new Fisherman’s Wharf.

    Read More

  • Fishery Water Tank

    West Java, Indonesia

    Xypex products were used to repair faulty construction joints, honeycombs and other concrete defects in this above ground water containment tank at a Java fishery. All tank surfaces were then treated with two coats of Xypex Concentrate.

    Read More

  • Fleetwood Fresh Water Pump Station

    Surrey, British Columbia, Canada

    Xypex Concentrate and Modified were used to waterproof all exterior walls of this pump station.

    Read More

  • Flinders Ports Berth 8 Outer Harbour Grain Wharf

    Adelaide, Australia

    Corrosion resistance, durability and an extended service life with reduced maintenance costs were key priorities for Flinders Ports in the recent construction of their new Berth 8 Outer Harbour Grain Wharf.

    Read More

  • Football Stadium

    Valencia, Venezuela

    After other waterproofing systems had been tried without success, a total of 6,800 kgs (15,000 lbs) of Xypex Concentrate was used to completely waterproof the concrete stands of this Valencia stadium. 

    Read More

  • Franklin Quest Field

    Salt Lake City, Utah, USA

    Xypex products were used to stop severe leaking of the wall and floor joint in the below-grade batting tunnel.

    Read More

  • Freixenet Champagne Caves

    Sonoma, California, USA

    Xypex crystalline waterproofing was used extensively at this new winery. Areas of application included champagne storage caves and cellars, tunnels, tower walls of visitor centre, retaining walls and slabs.

    Read More

  • Fujitsu Computer Factory – Phase 1 & 2

    Bien Hoa, Dong Nai, Vietnam

    Repaired the roof of an utility building in Phase 1 and waterproof the roof of the canteen building in Phase 2. 

    Read More

  • Fukushima Daiichi Nuclear Power Station

    Ōkuma, Fukushima, Japan

    Xypex Concentrate was applied to the floor and walls of the waste fuel storage pool facility to ensure the total impermeability and durability of the concrete.

    Read More

  • G.K. Piramal Memorial Charitable Hospital

    Mumbai, India

    Xypex products were used to waterproof the sloping roof, terrace, drainage gulleys and toilets of this hospital.

    Read More

  • Gabcikovo Dam

    Gabcikovo, Slovakia

    Before repairing and waterproofing the entrances and corridors leading to the water locks of this dam, the concrete surface was first cleaned with a high-pressure cleaning unit. A two-coat application of Xypex Concentrate and Modified was then applied to the surface. Cracks and joints were filled and sealed with Xypex Patch'n Plug.

    Read More

  • Galitsino Water-Purifying Complex

    Galitsino, Russia

    Xypex Patch'n Plug and Xypex Concentrate were used to waterproof and protect the walls, floors and ceilings of the receiving reservoirs, purification system and pump station in this complex.

    Read More

  • Garage Roof

    Sines, Portugal

    Xypex Admix C-1000 NF was selected over a number of other products as the most effective solution to the waterproofing of 20 garage roofs.

    Read More

  • Gefionspringvandet (Gefion Fountain)

    Copenhagen, Denmark

    Water leakage in the reservoir under the pumphouse was successfully stopped after Xypex Concentrate and Patch'n Plug were applied to both the positive and the negative sides. The statue and the four pool slabs were removed and new slabs were cast with Xypex Admix blended into the concrete mix. Xypex Concentrate and Modified were applied to the existing pool walls.

    Read More

  • General Electric/Ctrl Puerto Nuevo De Cicios Convi

    Buenos Aires, Argentina

    All tunnels and water supply structures, with walls 0.65 m thick, were treated with Xypex Admix C-2000. Xypex Concentrate was used to waterproof the basements.

    Read More

  • General Motors Wastewater Treatment Plant

    Rosario, Argentina

    A two-coat treatment of Xypex Concentrate and Modified was applied to all the concrete surfaces of this effluent-treatment plant.

    Read More

  • Gloria Ferrer Winery – Champagne Caves

    Sonoma, California, USA

    In 1982 the Ferrer family of Spain, proprietors of the world’s largest producer of sparkling wine – Freixenet U.S.A. – purchased 250 acres of land in Sonoma’s Carneros wine district; they then planted vineyards with the traditional sparkling wine grapes Pinot Noir and Chardonnay. 

    Read More

  • Goiânia Wastewater Treatment Plant

    Goiânia, Goiás, Brazil

    Xypex Concentrate was spray-applied to the foundation walls and floor of this wastewater treatment plant to waterproof and protect the concrete.

    Read More

  • Goldbar Wastewater Treatment Plant

    Edmonton, Alberta, Canada

    Xypex Admix C-1000 and Xypex Dryshake DS-1 were used to waterproof the holding structures at this waste activated sludge facility. Concrete containing Xypex Admix exceeded the specified mix design strengths at the 28 day tests. The contractor also observed less shrinkage in the Xypex-treated concrete.

    Read More

  • Goldhill Complex

    Singapore

    Over 23,000 kgs (50,700 lbs) of Xypex crystalline waterproofing were applied to basement R.C. floor slabs and walls of this large shopping mall and office complex in Singapore. The application also included the treating and dry-packing of all construction joints with Xypex Concentrate.

    Read More

  • Gondola Counterweight Chamber

    Tignes, France

    The Xypex waterproofing system was applied to water channels and to all interior surfaces of this gondola chamber at Tignes. The concrete shaft is embedded in a glacier at an altitude of 3,200 m (10,500 ft.). Total area treated with the Xypex system was approximately 1,050 m2 (11,300 sq. ft.).

    Read More

  • Grain Elevator Chamber – North Harbor

    Gdansk, Poland

    The foundation walls and slab of this grain elevator chamber, situated 10 m below the underground salt water level, were waterproofed, using the ‘sandwich’ method and Xypex products.

    Read More

  • Grain Storage

    Pakruojis, Lithuania

    The concrete of these grain storage vaults were coated with Xypex Concentrate and Modified to protect the grain from the infiltration of ground water.

    Read More

  • Greenwich Private Residence

    Greenwich, United Kingdom

    South of the River Thames, the basement of this private residence suffered severe water ingress. A three-coat Xypex system was used to address the problem.

    Read More

  • Grimsel Dam System

    Grimsel Area, Switzerland

    Xypex crystalline waterproofing was used at dam sites in the Grimsel area of Switzerland. Areas of application included 10 ton cable car station which is built into rock, tunnel sections (concrete and shotcrete), valve house, power house entranceway, fresh water reservoir, retaining walls, transformer stations, and machine rooms.

    Read More

  • Guizhou Office Building

    Beijing, China

    The parking garages on the first and second basement floors of this building were waterproofed with Xypex Concentrate and Xypex Patch'n Plug.

    Read More

  • Győr City Sewage Purifying Plant

    Győr, Hungary

    Xypex Patch’n Plug was used to repair cracks and other defects in the concrete settlement basin of this wastewater treatment facility which was undergoing renovation and expansion. Xypex Concentrate was applied to over 1500 m2 surface area, after it was sandblasted.

    Read More

  • H.M. Suburban Fitness Park

    Mumbai, India

    Xypex products were successfully used to repair the cracks and faulty joints in the concrete of the terrace. Xypex was also applied to the basement walls, lift pits, generator room, cable trench, air washer rooms, toilets, kitchens, and bathrooms of this structure.

    Read More

  • Hagenbeck Zoo – Orang-Utan House

    Hamburg-Stellingen, Germany

    The concrete slope of the moat was poured in-situ to maintain the structural profile provided by the architect. Xypex products were used to waterproof the concrete after in-situ concrete manufacturers were unable to guarantee the impermeability of the supplied material.

    Read More

  • Hakuraa Club – Water Bungalow

    Meemu Atoll, Sri Lanka

    The concrete beams and soffits of 70 water bungalows and 370 concrete piers were waterproofed and protected with Xypex Concentrate and Modified.

    Read More

  • Halifax Harbour Solution Project

    Halifax, Nova Scotia, Canada

    Xypex Admix C-1000 was added to the concrete mix to provide waterproofing and chemical resistance.

    Read More

  • Hanahan Water Treatment Plant – Clearwell #3

    Charleston, South Carolina, USA

    Xypex Concentrate was used to waterproof and protect the wall and slab of this water treatment plant.

    Read More

  • Hanil Adetex Textile Mill

    Solo, Central Java, Indonesia

    The water treatment tanks at this large textile mill in Java were waterproofed with Xypex products. The top photograph shows the application of Xypex to the interior of one of the tanks, while the lower photograph shows the curing of the Xypex treatment.

    Read More

  • Hawaiian Telephone – Hilo Duct Line

    Hilo, Hawaii, USA

    Xypex Admix was added to the ready-mix to prevent water infiltration into this vault.

    Read More

  • Health Centre Swimming Pool

    Haapsula, Estonia

    Because of a rise in the ground water level, this swimming pool was waterproofed with Xypex Concentrate.

    Read More

  • Heathrow Airport – Terminal 5

    Hounslow, United Kingdom

    A combination of Xypex products was used to repair and waterproof the main service tunnel connecting Terminal 5 at Heathrow Airport with other terminals. Repairs with Xypex Concentrate and Xypex Patch'n Plug were so successful that Xypex Admix was specified on all remaining cast-in-place concrete. Over 5 tonnes of Xypex Admix C-1000 NF has been used to date on this project.

    Read More

  • Hektor, S.A. Office Building

    Warsaw, Poland

    The foundation plate, walls and construction joints were waterproofed with Xypex Patch'n Plug and Xypex Concentrate.

    Read More

  • Helicoid

    Caracas, Venezuela

    Due to the age of the building, the roof slab showed signs of serious deterioration and leaks. All the joints of the slab were treated with Xypex Dry-Pac followed by an application of Xypex Concentrate.

    Read More

  • Heuston Railway Station Tank Farm

    Ireland

    This petroleum storage facility, used by the railway, is situated adjacent to the Liffey River. Protection from contamination was a major environmental concern. Xypex Admix C-1000 NF was dosed at 1% to the PC content of the concrete used in the construction of two ‘bund tanks’ for secondary containment purposes.

    Read More

  • High Temperature Gas Reactor

    Oarai, Japan

    Areas of application included the entire floor area at the lowest level of the building. This level is where the helium reactor core will be installed. Temperatures in the reactor will be as high as 1,000 degrees centigrade.

    Read More

  • High Voltage Pylon

    Burgenland, Austria

    Xypex was used to repair the cracks and deteriorated concrete of 10 concrete pylons. These pylons, which form the base of towers carrying high voltage cables, were also treated with a slurry coat of Xypex Concentrate after repairs had been made.

    Read More

  • Highway 51 Bridge Repair

    Madison, Wisconsin, USA

    Xypex Admix C-2000, mixed at a rate of 2% by weight of cement, significantly reduced the problem of cracking on the bridge. As a test, one parapet wall was placed using Xypex Admix while a second wall was cast without the Xypex. The Xypex treated concrete had 50% fewer cracks than the reference parapet wall.

    Read More

  • Highway Program

    Skala, Slovakia

    A two-coat application of Xypex Concentrate and Modified was used to waterproof the run-off channels and pits where highway water carrying oils and chemicals is collected.

    Read More

  • Hisense Arena

    Melbourne, Australia

    Xypex Admix C-1000 NF was blended into the concrete mix to waterproof and protect the precast bleachers for this multipurpose stadium (formerly named the Vodafone Arena). The seating design of this stadium is stunningly innovative and the contractors used the latest technology to ensure that the arena would accommodate a wide range of functions.

    Read More

  • Holding Reservoir, Skoda A.S.

    Czech Republic

    A two-coat application of Xypex Concentrate and Modified was applied to the concrete exterior of this new holding reservoir for technological liquids. To ensure proper curing, the surface was protected from the strong summer sunlight with a textile material.

    Read More

  • Holland Pump Station

    Netherlands

    Xypex products were utilized in the renovation of this wastewater pump station. Xypex Concentrate was used to seal around pipes and at the base of pumps. Xypex Restora-Top 100 was used to resurface the concrete decks outside the pump station.

    Read More

  • Hollywood Casino Parking Garage

    Shreveport, Louisiana, USA

    Red Xypex Admix C-1000 was used to waterproof (and color) the top deck of this 70,000 sq.ft. casino parking garage. A total of 40,000 lbs. of Xypex Admix was used.

    Read More

  • Homebush Bay Aquatic Centre

    Homebush Bay, Australia

    Before tiles were laid, a coating of Xypex Concentrate was applied to the fine shrinkage cracks in the formed walls of the pool areas throughout the complex.

    Read More

  • Hongta Sports Center

    Yunnan Province, China

    The main courts and gymnasium of this large-scale sports facility plus the football stadium bleachers, were waterproofed with Xypex products.

    Read More

  • Hotel Deputatilor

    Bucharest, Romania

    Xypex Concentrate was applied to prevent water seepage and mortar, dosed with Xypex Admix was applied to the construction joints.

    Read More

  • Hotel Hrizantema

    Sunny Beach, Bulgaria

    The below sea-level concrete foundation was waterproofed with Xypex products. 300 meters of joints were also treated using Xypex.

    Read More

  • Hotel Mirabeau

    Monaco

    Xypex products were applied to the swimming pool at this hotel in Monaco. After repair of cracks with Xypex Patch'n Plug, the pool received a two-coat application of Xypex Concentrate and Modified.

    Read More

  • Hotel Trakia

    Burgas, Bulgaria

    The hotel’s concrete foundation, located below sea level, was waterproofed with Xypex products. The application had to be executed on both the negative and positive side. 450 meters of expansion joints, in the middle of the building, were also treated with Xypex.

    Read More

  • Hotel Zalec Casino

    Celje, Slovenia

    Xypex Admix C-1000 was blended into the concrete mix and installed in the foundation slab of this building to waterproof and protect the concrete from deterioration.

    Read More

  • Huaylacancha Dam

    Huancayo, Peru

    Xypex Patch'n Plug was used to repair cold joints after the parge coat was removed from the upstream and downstream faces of this dam. Both Xypex Concentrate and Xypex Modified were used to waterproof the upstream face while a single coat of Xypex Concentrate was all that was needed on the downstream face.

    Read More

  • Hukou Bridge

    Jiujiang, China

    The four lane Hukou bridge over Lake Panyang is 3 km from the Yangtze river and is the longest bridge on the expressway between Jiujiang and Jingdezhen. Xypex products were used to repair and waterproof the barriers, construction joints and guy-rope locations of the bridge structure.

    Read More

  • Hydro Electric Power Station

    Turawa, Poland

    Xypex Concentrate and Modified were applied as negative side waterproofing to stop leakage in the drop block area of this dam.

    Read More

  • Hydrotechnical Complex

    Volgograd, Russia

    This hydro-technical complex consists of four buildings of reinforced concrete. Each building contains five reservoirs, 3.8 m deep. Another building contains a reservoir, used to store and dispense purified water. 14 tons of Xypex Concentrate, Modified and Patch'n Plug was used to repair and waterproof the joints and surfaces of this complex.

    Read More

  • I-405 Interchange – Pre-Cast Storage Units

    Washington, USA

    Over 4,000 lbs. of Xypex Concentrate was applied to these pre-cast storage units. A few light mistings of Xypex Gamma Cure were used to speed the curing process. All Xypex waterproofing tasks were accomplished prior to shipment to the job site.

    Read More

  • IBM Building

    Caracas, Venezuela

    reinforced concrete roof slab of the IBM office building showed severe leakage. Because heavy equipment and machinery were being stored on the slab, waterproofing was performed from the negative side using Xypex Concentrate.

    Read More

  • I-Flex Solutions

    Bangalore, India

    The planter boxes and podiums in the basement of this structure were treated with Xypex products to waterproof and protect the concrete.

    Read More

  • Ilda Dam

    Kasama, Japan

    Xypex products were used to stop water seepage through construction joints on the downstream face of this dam located in Ibaraki Prefecture. The photographs show the dam face before and after the Xypex application. The prime contractor for the project was Toda Gene Co., Ltd. and the Xypex application was completed during 1991.

    Read More

  • Illuminada Condominiums

    Edmonton, Alberta, Canada

    Xypex Admix C-1000 was added to the concrete to waterproof and protect the parkade walls and three levels of underground parking.

    Read More

  • Incineration Plant

    Prague, Czech Republic

    The Xypex system was used at this plant to seal the water treatment tank and to repair various leakage problems occurring in the fuel station. All leakage was completely stopped using the Xypex system.

    Read More

  • Institute of Wiglav

    Warsaw, Poland

    The walls and ceiling of this newly built fire control reservoir were waterproofed with Xypex Concentrate.

    Read More

  • Interactive Underground Restaurant – Darling Harbour

    Sydney, Australia

    Xypex Admix was used in 3,700 m3 of concrete to waterproof the hydrostatic slab, pits, tanks, walls and podium.

    Read More

  • Interamerican University School of Law

    San Juan, Puerto Rico

    Two coats of the Xypex system were applied to exterior slabs of terrace areas, after which a finished concrete topping was placed. The Xypex application was performed at night time, while the topping was poured in sections the following mornings. This was done so as to obtain optimum conditions for surface bonding and curing.

    Read More

  • International Business Center

    Warsaw, Poland

    The water tanks in this business center are used for fire prevention. A two-coat Xypex treatment of Xypex Concentrate and Modified was used to waterproof the structures.

    Read More

  • Investment and Development Bank

    Poprad, Slovakia

    A two coat application of Xypex Concentrate and Modified was used to protect and waterproof the below-grade walls and slab of this bank building. Xypex Dry-Pac and Xypex Patch'n Plug was used in the joints.

    Read More

  • ION Orchard

    Singapore

    Xypex was pleased to be selected by Penta-Ocean Construction Co. Ltd. as the specified concrete waterproofing product for another of their major construction projects: the prestigious 61,300 m2 ION Orchard retail mall in Singapore's prime retail district. 

    Read More

  • Iqaluit Wastewater Treatment Plant

    Iqualuit, Nunavut, Canada

    The concrete used in the initial construction of this plant was deemed very poor. A 5-1/2 in. reinforced shotcrete liner was used to rectify the problem. A two-coat application of Xypex Concentrate was used to waterproof the walls and slabs of the structure.

    Read More

  • Isla Trinitaria Potable Water Reservoir

    Guayaquil, Ecuador

    The potable water distribution system for Isla Trinitaria consists of a 1,450 m3 capacity water reservoir. 1,205 kg of Xypex Concentrate was used to treat the inside surface of the reservoir, and 285 kg of Xypex Patch'n Plug was used to repair sections of the floor/wall joints and to patch tie holes.

    Read More

  • J.A.M.E.S. Wastewater Treatment Facility

    Abbotsford, British Columbia, Canada

    The walls of the digester tank and the walls of the aeration tanks adjacent to the pipe gallery were waterproofed with a two-coat application of Xypex Concentrate and Modified.

    Read More

  • J.J. Paso Building

    Buenos Aires, Argentina

    The driveway into the underground garage was repaired and restored using Xypex Admix C-2000. Water had been leaking into the electric room below ground level.

    Read More

  • Jamsil Lotte World Complex

    Seoul, Korea

    The well-known Lotte Group developed this huge multi-purpose complex which includes a major hotel, shopping mall, department store, entertainment facilities, park and recreational areas. Xypex crystalline waterproofing was applied to all foundation and basement areas of the department store and shopping mall. 

    Read More

  • Jan 111 Sobieski Hotel

    Warsaw, Poland

    Xypex Patch'n Plug and Xypex Concentrate were used to remedy the original waterproofing membrane that had failed on the foundation walls and floors of this hotel.

    Read More

  • Janio Zuadros And Sebastiao Camargo Tunnels

    São Paulo, Brazil

    Xypex Patch'n Plug was used to seal 1,700 points of water seepage under high hydrostatic pressure. Two coats of Xypex were then shotcrete-applied to 2,600 m2.

    Read More

  • Japanese Consulate – Residence

    Ho Chi Minh City, Vietnam

    Repaired an old concrete roof and gutters where repeated repairs with membrane system were unsuccessful. All existing mortar and membranes were removed and a 2 coat application of Xypex Concentrate and Modified was applied over the concrete roof. A protection mortar topping was then applied over the Xypex coating. Total area treated was 60 m2 and completed in June, The main contractor is Hazama Corporation.

    Read More

  • Jarun Housing Estate

    Croatia

    Xypex Admix (2,450 kg) was added to the 700 m3 of concrete used to build the foundation and underground parking of this two-building housing estate. The treated slab was 60 cm thick and the walls 30 cm thick. Xypex Concentrate and Xypex Dry-Pac were also used on 300 m of both horizontal and vertical joints.

    Read More

  • Jianxiang Overpass Bridge

    Beijing, China

    The original Jianziang overpass was built in the 1980s to connect to the Bedaling expressway. The increase in traffic over the years resulted in the need to reconstruct and widen the overpass. Xypex products were used to waterproof this new overpass.

    Read More

  • Jim Thorpe Water Tank

    Jim Thorpe, Pennsylvania, USA

    Xypex Dryshake DS-1 was used in the manufacturing of the pre-stressed post-tensioned panels of this 200,000 gallon water tank.

    Read More

  • John G. Shedd Aquarium

    Chicago, Illinois, USA

    Xypex products were used at the prestigious Shedd Aquarium in Chicago, a project that has become well known because of the complexity of its construction and because it includes the world's largest enclosed artificial ocean. 

    Read More

  • Joyceville Correctional Institute

    Joyceville, Ontario, Canada

    Xypex products were used to waterproof and protect both the walls and slab of this building.

    Read More

  • J-PARC Synchrotron Tunnel

    Tokai, Ibaraki, Japan

    The Japan Proton Accelerator Research Complex (J-PARC) is a new high intensity proton accelerator using MW class high power beams up to 50 GeV – the highest beam power of any accelerator in the world.

    Read More

  • Kakaakoo Phase 2 – Vee Vault

    Honolulu, Hawaii, USA

    Xypex Admix was used to waterproof and thereby prevent any water penetration into this vault.

    Read More

  • Kardzali School Swimming Pool

    Bulgaria

    During the general repair of the swimming pool, Xypex Patch'n Plug was used to repair cracks, joints, and the areas where the pipes enter through the concrete.

    Read More

  • Karkheh Dam

    Iran

    Xypex Patch'n Plug and Xypex Concentrate were used to repair and waterproof the tunnel of this dam.

    Read More

  • Kaunas Bridge

    Kaunas, Lithuania

    The support columns of the old bridge were treated with Xypex Concentrate which was also used on the entire undersides of the two new bridges.

    Read More

  • Keystone Electric Loading Dock

    Long Island, New York, USA

    Xypex Megamix II was used to repair the extensively damaged concrete of this loading dock. Freeze-thaw, and close proximity to a harsh marine environment caused the deterioration.

    Read More

  • King County Aquatic Facility

    Seattle, Washington, USA

    Xypex products were used to waterproof the main competition pool, the diving tank and the warm-up pool at this complex built originally for the 1990 Goodwill Games in Seattle. 

    Read More

  • Kleppe Waterworks

    Kleppe-Bryne, Norway

    The tunnels and tanks at this underground waterworks project in Norway exhibited leakage in various areas due to cracks and defects in the concrete. All leakage was successfully eliminated by repairing the defects with Xypex products together with the application of a Xypex slurry coating to the surface.

    Read More

  • Kunming Hotel

    Yunnan Province, China

    Xypex products were used to waterproof the basement under the garden in front of this hotel.

    Read More

  • Kuwait City Hotel

    Kuwait

    Xypex Concentrate was used to waterproof and protect the foundation of this hotel.

    Read More

  • Kwame Nkrumah Memorial

    Accra, Ghana

    Xypex products were used extensively to waterproof the tomb and fountain areas of this memorial to Ghana's first President.

    Read More

  • La Llaveria Luxury Housing Project

    Santiago, Chile

    Xypex Concentrate, instead of the traditional membrane method, was used to waterproof the exterior of the foundation walls of 62 houses in this exclusive area of Santiago.

    Read More

  • Lake June Pump Station

    Dallas, Texas, USA

    The double Ts of this reservoir were first sandblasted and then treated with one coat of Xypex Concentrate followed by one coat of Xypex Modified. The Xypex treatment was used to prevent further penetration of chlorinated water which was attacking and corroding the reinforcing steel.

    Read More

  • Langley City Wastewater Treatment Plant

    Langley, British Columbia, Canada

    Xypex Concentrate was used to waterproof the exterior wall of the thickening tank at a rate of 2 lbs. per square yard. Xypex Concentrate, Dry-Pac and Patch'n Plug were used to waterproof 266 lineal feet of construction joints.

    Read More

  • Lascelles Wharf

    Geelong, Australia

    With a design mix that included Xypex Admix C-Series, these 20+ tonne, 40 MPa slabs were installed as part of a major upgrade of the Lascelles wharf facility.

    Read More

  • Le Meridien Hotel

    Limassol, Cyprus

    Xypex products were used to waterproof this sewage treatment facility being constructed at the new Meridien Hotel in Limassol. 

    Read More

  • Lewisburg Hospital – Utility Tunnel

    Lewisburg, Pennsylvania, USA

    Xypex Admix was used in lieu of a membrane system. The application was able to continue through the winter with a resulting cost-saving of 75%.

    Read More

  • Life Insurance Consortium

    Santiago, Chile

    Xypex was used to waterproof the underground parking area which was subject to dampness and water seepage due to the moisture from refrigeration units located on the top side of the slab. Because water continually ponds on the top surface, Xypex had to be applied to the ceiling or negative side of the slab.

    Read More

  • Limassol Private Villa

    Cyprus

    Xypex was used to waterproof all surfaces of this large swimming pool prior to the installation of ceramic tiles.

    Read More

  • Line A Subway Extension

    Buenos Aires, Argentina

    Xypex Admix C-2000 was used in complimentary underground structures as part of the renovation and expansion of the oldest subway line in South America.

    Read More

  • Lipovica Water Reservoir

    Belgrade, Serbia & Montenegro

    Xypex Crystalline Technology was the solution to the leaking areas of this old structure, in particular, the sealing of construction joints.

    Read More

  • Lithuania Water Treatment Plant

    Lithuania

    The concrete for this plant blended Xypex Admix C-1000 at 5 kg/m3 into its mix design. 

    Read More

  • Little Mountain Reservoir

    Vancouver, British Columbia, Canada

    Xypex Concentrate was used to waterproof and protect the new 175 million litre reinforced concrete tank in Queen Elizabeth Park. The previous underground reservoir was first demolished and Xypex Patch'n Plug was used to seal the cold joints and tie holes of the new structure.

    Read More

  • Lom Lines Overseas Mgt. Building

    Hamilton, Bermuda

    Xypex products were used in the concrete block fill and in the mortar joints for two floors of the below-grade perimeter reinforced masonry walls.

    Read More

  • London Dairy – Iffco

    Dubai, United Arab Emirates

    Following the ingress of water through the floor slab of this new dairy plant, Xypex Concentrate was successfully applied, completely stopping the water ingress. An epoxy coating was subsequently applied to the floor slab.

    Read More

  • Los Angeles Zoo

    Los Angeles, California, USA

    450 cu. yds. of Xypex Admix C-1000 was blended into the mix to waterproof and protect the concrete of the Seal exhibit tank.

    Read More

  • Lower Ruvu Water Purification Plant

    Dar Es Salaam, Tanzania

    Over 50 tons of Xypex crystalline waterproofing were applied to this large purification plant near Dar es Salaam. 

    Read More

  • Lyman Run Dam

    Galeton, Pennsylvania, USA

    Hairline cracking in the concrete spillway of the new Lyman Run Dam required sealing before dam construction completion.

    Read More

  • M8 Super Highway River Danube Bridge

    Dunavecse, Hungary

    Xypex Concentrate was applied to the concrete base rings of bridge pillars prior to the pillars being submerged in the Danube river. The Xypex treatment of these pre-cast components provided waterproofing and protection. Xypex Patch’n Plug was used to repair defects in the pillars and the seal joints between the rings.

    Read More

  • Macau Tower

    Macau

    Xypex products were used to waterproof and protect the foundations of this structure.

    Read More

  • Maksimilijan Warehouse

    Celje, Slovenia

    Xypex Admix C-1000 was blended into the concrete mix and installed in the 40 cm thick concrete slab of this warehouse complex to waterproof the concrete from the start. 

    Read More

  • Mamzar Centre

    Dubai, United Arab Emirates

    Xypex products were used to waterproof the bathrooms, kitchens and balconies of this multi-use complex with offices, residential apartments, and retail stores.

    Read More

  • Manila Peninsula Hotel

    Makati City, Philippines

    Xypex products were used to waterproof the lower swimming pool and the vaulted portion of the lower pediment.

    Read More

  • Mannheim Heating Tunnels

    Mannheim, Germany

    Xypex Concentrate (1,500 kg) was used to waterproof this 600 m long tunnel which is made up of segmented pre-cast units. The tunnels and chambers, which are exposed to very high temperatures, contain pipes for the central city heating system.

    Read More

  • Mao Water Treatment Plant

    Mao, Dominican Republic

    Xypex Concentrate and Modified were spray-applied to the floors and walls of this water treatment plant which was built by a Brazilian Company. The Xypex products were also shipped from Brazil.

    Read More

  • Maple Leaf Foods Rothsay Bio Filter

    Ontario, Canada

    Xypex Admix C-1000 was added to the concrete mix to waterproof and chemically protect this reservoir.

    Read More

  • Marmaris Hotel

    Marmaris, Turkey

    Xypex products were used to waterproof 22,300 m2 of basements, decks and swimming pools in this new luxury hotel near the Mediterranean Sea.

    Read More

  • Maybank

    Kuala Lumpur, Malaysia

    The Maybank project was the third largest continuous concrete pour in world history and the largest ever in South East Asia. The project used 70,000 lbs. of Xypex Admix C-2000 and required 60 hours to pour the foundation slab whose thickness varied from 3 ft. to 18 ft.

    Read More

  • Maydenbauer Reservoir Replacement Project

    Bellevue, Washington, USA

    Xypex products were used to waterproof and protect the interior concrete walls and decks of this reservoir. A total of 35,000 sq. ft. was treated.

    Read More

  • Mayport Naval Station

    Jacksonville, Florida, USA

    Xypex Concentrate and Patch’n Plug were used to repair 480 ft. of cracks. All concrete surfaces were then coated with Xypex concentrate and Modified.

    Read More

  • Mekwor Plaza

    Addis Abeba, Ethiopia

    Xypex was specified for extensive use on this office and apartment building. Xypex Concentrate and Modified were used to waterproof slabs, terraces, balconies, roofs, basement walls, flower planters and water fountains. Xypex Dry-Pac was used to waterproof expansion joints in conjunction with a suitable flexible sealant.

    Read More

  • Melbourne Aquarium

    Melbourne, Australia

    The below-ground aquarium tanks and viewing areas (adjacent to the Yarra River) exhibited leakage in various areas due to cracks and defective joints. All leakage was eliminated by using the Xypex concrete repair system (Xypex Concentrate and Patch’n Plug).

    Read More

  • Melbourne Zoo – Trail of Elephants

    Melbourne, Australia

    The Trail of the Elephants captures the imagination of visitors to the Melbourne Zoo, Parkville, engaging them in a sense of theatre, discovery and wonder, while delivering a serious message about the survival of the ‘endangered’ Asian elephant in its native habitat, and the conservation role of the contemporary zoo.

    Read More

  • Metropolitan Building

    Warsaw, Poland

    The Metropolitan is comprised of three separate, but linked buildings. Xypex products were used to waterproof both the construction joints and the foundation slab of this building.

    Read More

  • Metropolitan Mass Transit System

    Antwerp, Belgium

    Xypex products were used to seal the entrance and exit portals on all 13 stations. Differing construction methods in the tunnel and station portions allowed strong ground-water ingress at the joints and Xypex was specified for use after extensive testing. Work was carried out at depths of 65 - 185 ft. below the water table.

    Read More

  • Mexico City Subway Line B

    Mexico City, Mexico

    Xypex Patch'n Plug and Xypex Concentrate were used to stop extensive water leaks and to waterproof and protect the concrete throughout the subway’s Line B.

    Read More

  • Microsoft Building

    Sydney, Australia

    Xypex Admix C-1000 was used to dose 1,200 m3 of concrete on the roof deck of this office building.

    Read More

  • Middleburg Wastewater Treatment Plant

    Middleburg, Virginia, USA

    All exposed concrete of the new, cast-in-place tanks were waterproofed with a two-coat application of Xypex Concentrate and Modified. The operations building and garage were also waterproofed with Xypex products.

    Read More

  • Mill Dam

    Dobrzen, Poland

    The gallery walls of this dam were leaking because of strong hydrostatic pressure. Xypex Patch'n Plug and Xypex Concentrate were applied to prevent any further water infiltration.

    Read More

  • Minato-Mirai Central Station Conduit

    Yokohama, Japan

    Xypex Concentrate was spray-applied to the walls of this 170 m utility tunnel which is used for the cable and lines carrying gas, telephone and electrical power. Xypex Concentrate was also used in a sandwich application on the concrete slab and Xypex Patch'n Plug was used to repair holes, joints and cracks.

    Read More

  • Mini Storage

    Harmon, Guam

    The repair and waterproofing of cracks and joints in the pre-cast roof of this Mini Storage facility were carried out using Xypex Patch'n Plug and Xypex Concentrate.

    Read More

  • Ministry of Finance

    Putrajaya, Malaysia

    4,325 m3 of Xypex Admix C-2000 NF was used to waterproof and protect the bottom of the raft slab in the one-level basement of this landmark government structure. The water feature at the front of the building was waterproofed with Xypex Concentrate and Modified.

    Read More

  • Mio Wastewater Treatment Plant

    Mio, Michigan, USA

    Xypex products were used to waterproof the concrete slab of this wastewater treatment plant for the Mentor Utility Authority.

    Read More

  • Mladá Boleslav Reservoir

    Mladá Boleslav, Czech Republic

    During the construction of this reservoir, the construction joints, floors and walls were treated with Xypex Concentrate. The cracks were sealed with Xypex Patch'n Plug.

    Read More

  • Mobil Oil Gas Station

    Dededo/Mangilao, Guam

    Xypex Concentrate and Modified were used to waterproof the split block walls of the “On the Run” convenience store in this Mobil gas station.

    Read More

  • Momina Klisura Power Plant

    Momina Klisura, Bulgaria

    The underground utility channel in this electric power plant was leaking. Joints and cracks were treated with Xypex Patch'n Plug followed by a coat of Xypex Concentrate.

    Read More

  • Moody Park Kinsmen Pool

    New Westminster, British Columbia, Canada

    This 50 year old swimming pool developed extensive cracking around the perimeter wall and floor slab joints. A standard crack repair was carried out using Xypex Concentrate, Patch'n Plug and Shotcrete 100.

    Read More

  • Morgan Creek Sewage Pump House

    Surrey, British Columbia, Canada

    Overhead shrinkage cracks in the ceiling of this pump station were repaired using Xypex Concentrate, Patch'n Plug and Xycrylic Admix.

    Read More

  • Morumbi Stadium

    São Paulo, Brazil

    Xypex Concentrate and Modified were applied to the concrete roofing above the seating area to prevent leakage due to rain. Various concrete structural problems around the stadium were also repaired with Xypex products.

    Read More

  • Moscone Center – Fountains

    San Francisco, California, USA

    Xypex Admix C-2000 was used to waterproof the decorative pools located above the exhibition floor on the plaza deck of the convention center extension. Approximately 500 cu. yds. were treated with Xypex.

    Read More

  • Moscow War Memorial

    Moscow, Russia

    Xypex products were used to waterproof the inside surfaces of the concrete, reinforced concrete and brick underground structures. These structures included the water-gauge point, transport tunnel, dispatching office, pump station and several fountains. The joints and cavities were filled with water due to leaks caused by high hydrostatic pressure.

    Read More

  • Multi-Level Parking Garage

    Warsaw, Poland

    The ceiling of this parking garage was waterproofed with Xypex Concentrate while construction was in progress.

    Read More

  • Mumbai Hilton Hotel

    Mumbai, India

    4,000 m2 of terraces and 1,500 m2 of the service floor of this Hotel were treated with Xypex Concentrate. Six months after the Xypex application, an inspection confirmed the success of the Xypex waterproofing process and also noted a 9% increase in the compressive strength of the concrete.

    Read More

  • Music Academy

    Bydgoszcay, Poland

    The below grade brick walls of this music academy were repaired by applying a cement mortar parge coat followed by one coat of Xypex Concentrate for waterproofing.

    Read More

  • Nagata Ward Office

    Nagata, Japan

    This building, which was damaged by the Kobe earthquake, showed no signs of leakage where Xypex materials were applied. Xypex Dryshake was used to waterproof the open deck on top of the parking lot and the roof garden was waterproofed with Xypex Concentrate and Modified.

    Read More

  • Nasa Neutral Buoyancy Lab

    Houston, Texas, USA

    A two-coat application of white Xypex Concentrate was used to waterproof and protect the concrete of the 50,000 sq. ft. Nasa Neutral Buoyancy Lab Tank. This tank was used to prepare and to train astronauts for the construction of the proposed space station. White Xypex eliminated the need for a separate white coating.

    Read More

  • National Bank of Czech Republic

    Prague, Czech Republic

    The floor of this building was leaking heavily. After the floor was drilled out to the foundation concrete, Xypex Concentrate, Modified and Patch'n Plug were used to stop the heavy leakage.

    Read More

  • National Bank of Slovakia

    Bratislava, Slovakia

    A membrane waterproofing system with Xypex as a secondary level of protection was the original specification for this Bank building. On completion of construction, it was found that the membrane had failed; the Xypex system was the only waterproofing system protecting the building.

    Read More

  • National Commission for Water

    Mexico City, Mexico

    A two-coat application of Xypex Concentrate was used to repair and waterproof the exterior and interior of this potable water tank. Xypex Patch'n Plug was used to repair concrete cracks and fissures.

    Read More

  • National Millennium Monument

    Beijing, China

    The National Millennium Monument was designed to announce and welcome the 21st Century. All the exposed surfaces of the monument were treated with Xypex Concentrate and Modified.

    Read More

  • Natural Stone Railway Bridge

    Germany

    This natural stone railway bridge was leaking badly on the underside of the arch. The problems were addressed with Xypex Concentrate and Xypex Patch'n Plug plus a covering of shotcrete containing Xypex Admix C-1000 NF at a dosage rate of 2%. The structure is now completely impermeable.

    Read More

  • Nazarabe-Hirayama Tunnel

    Japan

    Xypex Crystalline Technology and Xypex Concentrate proved successful in sealing the 3 mm cracks in this 1,413 m tunnel, where significant leakage was occurring. Larger cracks and rock bolts were also repaired, using normal Xypex repair procedures. All leakage was stopped.

    Read More

  • Neighborhood Retail Building – Mission Bay

    San Francisco, California, USA

    Xypex Dryshake DS-1 was trowel applied to the foundation pilings of this building. Xypex Admix C-1000 was used in the concrete mix for the elevator pits.

    Read More

  • Neiva/Florencia Road Tunnel

    Neiva/Florencia, Colombia

    This tunnel is situated on the Neiva/Florencia road and was treated with approximately 3,000 kg of Xypex Concentrate to stop water penetration.

    Read More

  • Nepal Share Markets Company

    Kathmandu, Nepal

    All exposed roof slabs, decks and terraces were treated with Xypex Concentrate. Areas treated with Xypex Dry-Pac were also given a coat of Xypex Modified.

    Read More

  • Nepal Telecommunications Building

    Kathmandu, Nepal

    Approximately 7,700 kg (17,000 lbs) of Xypex Concentrate and Modified were applied to concrete foundations at the new Central Office Building of the Nepal Telecommunication Corporation. 

    Read More

  • Nescopeck Wastewater Treatment Plant

    Nescopeck, Pennsylvania, USA

    Xypex Admix was used to waterproof and protect a new tank that would be subjected to a harsh environment. Over 1,200 cu.yds. of concrete was treated with Admix C-1000 at 12 lbs/yd3.

    Read More

  • New Jersey Dot Hightstown Bypass

    Hightstown, New Jersey, USA

    Xypex Admix C-1000 was added to the concrete mix to waterproof and protect the eight bridge decks, parapet walls, and primary and secondary relief slabs of both the bridges and the roads of this 3.5 mile highway. Concrete was dosed at 12 lbs/yd3.

    Read More

  • New Orleans Concrete Manholes

    New Orleans, Louisiana, USA

    Xypex Admix was blended into the mix design to waterproof and to protect these manhole rings from chemical and chloride penetration. Xypex Admix ensures that the manholes are waterproofed from the moment the concrete is poured.

    Read More

  • New Woodland Checkpoint – Border Crossing

    Singapore

    Xypex Admix C-2000 was used to waterproof all concrete foundations, including basement slabs, retaining walls, and the ground-level slabs to be covered with earth for landscaping. Xypex Concentrate and Dry-Pac were used to repair and waterproof all construction joints.

    Read More

  • Newberry Wastewater Treatment Plant

    Newberry, Michigan, USA

    Xypex Admix was used in the concrete mix to waterproof all walls and walkways. Xypex Dryshake DS-1 was used to waterproof the slabs. This was the second Xypex application for this site.

    Read More

  • Niagara Falls Water Treatment Plan

    Niagara Falls, New York, USA

    Xypex was selected over other products for the waterproofing and protection of the walls and slabs of this water treatment plant.

    Read More

  • Nice Water Treatment Plant

    Nice, France

    The Xypex crystalline system was used extensively for the waterproofing and protection of concrete tanks and mechanical chambers at this new water treatment facility in Nice.

    Read More

  • Nii Road Tunnel

    Japan

    The concrete of this 30-year-old, 1,290 m tunnel was subject to continuous leakage and freeze-thaw cycles. Repairs, using conventional membrane systems had repeatedly failed. Xypex Crystalline Technology and products were then selected to treat all problem cracks. The application was successful and the leakage was finally stopped.

    Read More

  • Nikko-Kensei Road Tunnel

    Japan

    This 50-year-old road tunnel, located in the mountains, had a problem with acid rain leakage which was causing major corrosion as well as concrete deterioration due to freezing conditions. The previous membrane repairs failed and Xypex was successfully used to repair the cracks and joints. All leakage was stopped.

    Read More

  • North Beach Garage

    San Francisco, California, USA

    Xypex Concentrate was used to waterproof the top deck of the post-tensioned slab and ramps of this five-storey parking structure. Ninety feet of Xypex FCM was used below the top deck to seal boxes for post-tensioning cables. Paint adhered well to the Xypex FCM strip. Xypex Concentrate and Gamma cure helped produce a hard, durable surface.

    Read More

  • Norway House

    Warsaw, Poland

    The 1 m thick foundation floor of Norway House is 15 m below grade. Xypex Patch'n Plug was applied to the concrete cracks and cavities followed by a slurry coat of Xypex Concentrate.

    Read More

  • NTT Headquarters

    Tokyo, Japan

    Xypex products were used to waterproof the crawl space designed for telephone cables, 40 m below ground-level.

    Read More

  • Ocean Park Tower 1

    Panama

    The social area of this new luxury condominium complex was designed for the top of the last parking deck. The 6 parking decks hold approximately six hundred cars. With cars coming in and out on a regular basis, the contractor was concerned about the high probability of future water leaks through cracks caused by vibration. 

    Read More

  • Office Building

    Mechanicsburg, Pennsylvania, USA

    13,000 sq. ft. of foundation walls and floors was treated with the Xypex system. Based on a design/build cost analysis, Xypex was more competitive than a standard membrane system.

    Read More

  • Office Building – Parking Garage

    Paris, France

    This prestigious office development overlooking the Seine developed substantial water ingress in its five storey below-ground car park. A two-coat application of Xypex Concentrate and Modified solved the problem and the basement is now completely dry.

    Read More

  • Ogrezeni Dam Spillway

    Bucharest, Romania

    This structure is located on the Arges River, 25 km west of Bucharest. The reservoir was created to provide added security and quality to the water supply. 

    Read More

  • Okachimachi Tunnel

    Japan

    Xypex products were used to waterproof various areas of the Okachimachi Tunnel which forms a section (495 metres) of a new artery created for Japan's famous Bullet Trains linking the Tokyo and Ueno Stations. 

    Read More

  • Olympic Games Monument

    Seoul, Korea

    This monument with the Olympic symbol was built for the 1988 Olympic Games in Seoul and is located at the Olympic Park site. A two coat application of Xypex Concentrate and Modified was applied to all fountain areas surrounding the monument and to foundation walls and slab of a cultural display facility constructed under ground. The total area treated was 4,000 m2 (43,000 sq. ft.).

    Read More

  • Olympic Park Train Station

    Homebush Bay, Australia

    Xypex Admix C-2000 was used in the concrete mix to waterproof the elevator pits in this train station.

    Read More

  • One & Only Resort Pool

    Cape Town, South Africa

    Xypex products were specified to waterproof and protect various areas of this One & Only Resort project, including two undersea tunnels, lift shafts, health spa pools, day water tank, penthouse swimming pool and the main one-million liter swimming pool (pictured here). Four Xypex products were used: Admix C-1000, Concentrate, Modified and Patch’n Plug.

    Read More

  • Opaczewska Street Housing Estate

    Warsaw, Poland

    The cellars of this housing estate were built below the ground water level. Xypex Patch'n Plug was used to repair cracks and Xypex Concentrate to waterproof the walls and slab.

    Read More

  • Optima Building

    Glasgow, United Kingdom

    35 tonnes of Xypex Admix C-1000 NF were used to waterproof and protect the concrete walls and slab of this carpark.

    Read More

  • Orpington Water Treatment Plant

    Orpington, United Kingdom

    Upon completion of this newly constructed water treatment tank, substantial cracking occurred in the walls. The cracks were treated with Xypex Concentrate and re-profiled with Xypex Patch'n Plug. Xypex Concentrate and Xypex Modified were then applied. Further inspection has shown no further leakage.

    Read More

  • Pacaembu Football Stadium

    São Paulo, Brazil

    The bleachers in this stadium were treated with a two-coat application of Xypex Concentrate and Modified. Xypex Admix was added to the concrete mix to waterproof the stadium’s access ramp.

    Read More

  • Pacific & Richards Streets Condominiums

    Vancouver, British Columbia, Canada

    Xypex Concentrate was used on all exposed above-ground construction joints. Xypex Patch'n Plug was applied to the tie holes in the underground garage.

    Read More

  • Palacio Legislativo Cisterns

    Mexico City, Mexico

    The water storage cisterns of the Palacio Legislativo" (house of senators) in Mexico City were treated with two coats of Xypex Concentrate. Total surface area was 2,000 m2 (21,500 sq. ft.). Prior to the Xypex treatment, a previously installed material was removed with high pressure water blasting and all cracks were repaired using Xypex Patch'n Plug.

    Read More

  • Palmovka Park Parking Deck

    Prague, Czech Republic

    Xypex Concentrate and Xypex Dryshake (DS-1) were used on the parking level of this multi-purpose building near the River Vltava, to waterproof the concrete structure against water seepage.

    Read More

  • Palo Alto Wastewater Treatment Plant

    Palo Alto, California, USA

    Xypex Patch'n Plug was used to repair the cracks on the roof of the digester tank. Xypex Concentrate was then applied over all areas.

    Read More

  • Panama Canal – Chamber Walls & Gatun Lock Culverts

    Panama

    The Panama Canal is an engineering and economic miracle. Since 1914, it has been a conduit of world importance, providing a link between two great oceans, a passageway annually for more than 14,000 vessels carrying more than 200 million tonnes of cargo.

    Read More

  • Paris Metro System

    Paris, France

    Xypex products were used to seal cracks, joints and water infiltration in various areas of the new and old subway tunnels and stations in this system. The success of these repairs was a major factor in the selection of Xypex by the city of Antwerp for use in their remedial program.

    Read More

  • Parking Deck

    Tallinn, Estonia

    Approximately 100 meters of joints and cracks between the decks and walls were routed out, filled with Xypex Dry-Pac followed by a slurry coat of Xypex Concentrate.

    Read More

  • Pearl Harbor Navy – Octagon Vault

    Honolulu, Hawaii, USA

    Xypex Admix C-2000 was added to the concrete mix design to waterproof the electrical vault which was subsequently submerged underwater.

    Read More

  • Peninsula Corporate Park

    Mumbai, India

    Four buildings make up this corporate park, located in Lower Parel, on the Arabian Sea coast. Xypex products were used in all four buildings, on 30,000 m2 of retaining walls and podium.

    Read More

  • Pennsylvania Turnpike

    Pennsylvania, USA

    Because of severe winter conditions and the extensive use of de-icing chemicals, the concrete median barriers and retaining walls of the Pennsylvania Turnpike were deteriorating at a very fast rate.

    Read More

  • Pershore Private Residence

    United Kingdom

    Previous attempts to waterproof this pool were unsuccessful. The owner, a structural engineer, then tried a three-coat Xypex treatment. Xypex Concentrate was used for the first and second coat. Xypex Modified was mixed into the render as the third and final coat. Xypex Patch'n Plug was used to repair structural defects. The application proved a complete success.

    Read More

  • Perwira Affin Bank

    Shah Alam, Malaysia

    Xypex Admix C-2000 NF was used to waterproof and protect the basement slab and other foundation sections. The slab is five levels below ground and is subject to considerable hydrostatic pressure.

    Read More

  • Petrzalka Sewage Treatment Plant

    Bratislava, Slovakia

    Xypex was used to repair the existing concrete structure of the sludge digester tank. Two coats of Xypex Concentrate and Modified covering a total of 1,658 m2 was applied to the floors and walls of the tank. Xypex Dry-Pac was used to seal the joints and cracks. A one-coat application of Xypex Concentrate was also used on the sloping concrete surface.

    Read More

  • Piasecki Building

    Warsaw, Poland

    The construction joints of the foundation slab and walls of this building were waterproofed with Xypex products.

    Read More

  • Pine Creek Wastewater Treatment Plant

    Calgary, Alberta, Canada

    Xypex Concentrate and Modified (180,000 lbs.) were used to waterproof and provide chemical protection for the first phase of this major wastewater treatment facility (400,000 sq. ft.), while Xypex Admix C-500 was incorporated into the 75,000 sq. ft. slab.

    Read More

  • Police Training Swimming Pool

    Kunming, China

    The pool is supplied with underground water at 80ºC. Xypex Concentrate and Modified were used to waterproof the underground passages and the interior walls of the pool.

    Read More

  • Ponta Do Ismael Water Treatment Plant

    Manaus, Brazil

    Situated on the bank of the Black river, this water treatment plant was spray-applied with Xypex Concentrate and Modified to waterproof and protect the concrete slab and walls.

    Read More

  • Pool and Spa House

    Clarus, Bermuda

    Xypex Admix C-1000, Xypex Concentrate and Modified were used to waterproof and protect much of the concrete in this pool and spa.

    Read More

  • Port Authority HQ

    Constanta, Romania

    Constructed in 1904, this building had seriously deteriorated concrete due to salt water ingress. The owner wanted the basement rehabilitated for additional office space. 

    Read More

  • Port of Guayaquil

    Guayaquil, Ecuador

    During April and May of 2004, the Ports Administration of Ecuador retained Xypex to assist with the repairs of the dock surfaces. The surfaces had characteristics that required Xypex Admix C-2000 to render the concrete impermeable against liquids and other aggressive substances. The Xypex treatment also protected the reinforcing steel and thereby helped prolong the life of the structure.

    Read More

  • Port St. Charles Marina

    Barbados

    Xypex products were used to waterproof and protect the concrete of all marine work, pools, and water tanks.

    Read More

  • Post Graduate Hospital Project

    Dhaka, Bangladesh

    The VIP cabin block and the surrounding area was waterproofed and protected with Xypex products.

    Read More

  • Potable Water Reservoir

    Plovdiv, Bulgaria

    Six reservoirs in the Plovdiv region were treated with Xypex. All reservoirs were 40 - 50 years old, and all were experiencing considerable leakage problems. A two-coat application of Xypex Concentrate and Modified, plus a render with Xypex Admix, was used to bring the reservoirs to an acceptable condition. Patch'n Plug was used for crack and joint repair.

    Read More

  • Potable Water Reservoir

    Tartu, Estonia

    Xypex Concentrate was used to waterproof the walls and slab of this potable water reservoir. Xypex Modified was used to protect the ceiling and Xypex Patch'n Plug was used around the sealing pipe areas.

    Read More

  • Potable Water Reservoir

    Parksville, British Columbia, Canada

    Xypex Admix was blended with 4,800 MPa concrete to waterproof and protect this reservoir structure.

    Read More

  • Potable Water Reservoir

    Copenhagen, Denmark

    The casting joints and cracks of this potable water reservoir (Sonderso Vandvaerk) were repaired and waterproofed using Xypex Patch'n Plug and Xypex Concentrate. Xypex Concentrate and Modified were spray-applied to the 500 m2 foundation wall. All work was carried out on the positive side.

    Read More

  • Potable Water Reservoir

    Ploiesti, Romania

    Xypex products were used to waterproof and protect four separate reservoirs.

    Read More

  • Potable Water Tanks

    Taipei, Taiwan

    This water treatment plant supplies three million people with drinking water. The 30 year old tunnel, 9,000 m in length, was treated with Xypex Megamix II for rehabilitation and to provide waterproofing.

    Read More

  • Potable Water Tanks

    Rakvere, Estonia

    Because of concrete shrinkage, cracks appeared in the walls of this water tank. The cracks were routed out, filled with Xypex Dry-Pac followed by a slurry coat of Xypex Concentrate.

    Read More

  • Potable Water Utility Tunnel

    Bratislava, Slovakia

    These tunnels, which house underground pipes and cables were severely leaking at a rate of up to 13,000 gallons every 24 hours. Xypex Patch'n Plug, Concentrate and Modified were used to repair 5,700 lineal ft. of cracks and to prolong the life of the concrete.

    Read More

  • Power Mast Footings

    Czech Republic

    This project took on the repair and reconstruction of old power mast footings within the Czech Republic, many using Xypex + Betosan products. The project is ongoing and has been running since 1996.

    Read More

  • Power Plant Szaszhalombatta

    Dunai Hoeromu, Hungary

    A two-coat application of Xypex Concentrate was used to waterproof an underground water-carrying channel (200 m long), separated by a concrete wall, from a channel serving as a utility tunnel. After 6 months of operation there were no signs of water leakage into the utility channel.

    Read More

  • Prague Airport

    Prague, Czech Republic

    This 1,206 meter utility channel located 4 meters underground serves as the main supply source of aviation fuel for the Knezevsi/Prague Airport. Xypex Patch'n Plug and Xypex Concentrate were used to prevent both water ingress and the leakage of aviation fuel into the soil.

    Read More

  • Precast Septic Tanks

    Nanaimo, British Columbia, Canada

    To ensure protection from an aggressive environment, Xypex Admix C-500 was added to the concrete mix at time of batching for these precast septic holding tanks.

    Read More

  • Premier Pacific Pinnacle

    Colombo, Sri Lanka

    Xypex Admix C-1000 NF was added to the concrete mix to waterproof the basements in this mixed development project.

    Read More

  • President’s Residence

    Tallinn, Estonia

    Xypex Concentrate was applied to the foundation walls and slab of the President of Estonia’s residence.

    Read More

  • Private Farm – Fertilizer Pit

    Cairo, Egypt

    These concrete fertilizer pits on a farm outside of Cairo had to be rendered impermeable to the attack of the chemicals used to decompose the material wastes within them. Xypex Concentrate was applied to the surface of the structures. Subsequent inspections indicated no leakage or deterioration of the concrete.

    Read More

  • Private Residence

    Pender Island, Canada

    The honeycombing and tie holes were repaired with Xypex Patch'n Plug. Xypex Concentrate was used to waterproof all interior walls and floors.

    Read More

  • Private Residence – Addis Abeba

    Addis Abeba, Ethiopia

    Xypex Concentrate was applied to the floors and base-board areas of the large bathrooms in this 3-story luxury home. A two-coat application of Xypex Concentrate and Modified was used to waterproof the balcony. All joints were routed out and treated with Xypex Concentrate and Patch'n Plug.

    Read More

  • Private Residence - Hong Kong

    Hong Kong

    Water was leaking into the rooms below the roof of this private residence. The old concrete topping was removed and the cracks were repaired with Xypex Patch'n Plug and Concentrate Dry-Pac. The total surface was then treated with two coats of Xypex Concentrate. A 5 cm topping was poured and ceramic tiles placed on top. All leaks were successfully stopped.

    Read More

  • Private Residence – Olympia

    Olympia, Washington, USA

    Xypex products were used extensively on this deluxe private residence. Xypex Concentrate was used to waterproof the interior walls of the equipment/electrical chase for the state of the art home theatre; Xypex Admix C-2000 was used to waterproof the inside lap pool and all exterior walls; a three-arch bridge spanning a water feature and used as a front driveway was also waterproofed with Xypex Admix; the shotcreted ornamental pools were coated with Xypex Concentrate and construction joints were sealed with Xypex Patch'n Plug.

    Read More

  • Private Residence – Springfield

    Springfield, Kentucky, USA

    Xypex Concentrate was used to waterproof and protect the foundation of this private residence.

    Read More

  • Private Residence Basement – Ben Gurion Airport Region

    Tel Aviv, Israel

    The below ground basement of this residence suffered from considerable leakage and was useable. All cracks, joints and other defects were repaired with Xypex system including Patch’n Plug and Dry-Pac. The entire basement area was coated with Concentrate and Modified to stop all leakage.

    Read More

  • Private Residence Cellar

    Kaunas, Lithuania

    Because of a high water level and extremely thin foundation walls, two coats of Xypex Concentrate were applied to the interior of the foundation, followed by a two inch parge coat. 

    Read More

  • Private Residence Sauna

    Lithuania

    The sauna of this private residence was waterproofed with a two-coat application of Xypex Concentrate and Modified.

    Read More

  • Private Swimming Pool

    Tallinn, Estonia

    The swimming and decorative pools of this private residence were waterproofed with Xypex Concentrate.

    Read More

  • PS Bank Building

    Makati City, Philippines

    Xypex Concentrate, Modified and Patch'n Plug were used to repair and waterproof several areas in this bank building. Xypex was applied to the fire protection tank, cistern tank, elevator pit, planters, garden deck, parking area, machine room deck, basement wall, entrance canopy, and radio room deck.

    Read More

  • Public Bank Technical Centre

    Bangi, Malaysia

    Xypex was used to waterproof 3,000 m3 of the basement floor and walls. Xypex was also used on the water tank and R.C. flat roof.

    Read More

  • Puerto Madero Office Building

    Buenos Aires, Argentina

    Xypex Dryshake DS-1 was used on the freshly poured foundation slab to waterproof and protect the concrete.

    Read More

  • Puerto Rico Coliseum

    San Juan, Puerto Rico

    Xypex products were selected to repair and waterproof a number of areas in this Coliseum, including: the perimeter wall, fire system cistern, potable water cistern, manholes and the pumping station tank. The project required approximately 7,500 lbs. of Xypex Concentrate, Modified and Patch'n Plug.

    Read More

  • Pump Station and Wastewater Treatment Plant

    Central Carbon, USA

    4,000 cu. yds. of Xypex Admix dosed concrete was used to waterproof this major pump station and wastewater treatment plant.

    Read More

  • Putra Mosque

    Putrajaya, Malaysia

    600 m3 of Xypex Admix C-2000 was used to waterproof and protect the water tank of this Mosque.

    Read More

  • Qantas Domestic Terminal – Kingsford Smith Airport

    Sydney, Australia

    Xypex Concentrate and Modified were used to waterproof and protect the footpath and roadway over the arrivals hall of this airport terminal. Xypex Gamma Cure was used to speed the curing process.

    Read More

  • Queensland Interchange

    Singapore

    Concrete dosed with Xypex Admix C-2000 NF was used in the construction of the reinforced walls of the depressed carriageways. Xypex Concentrate was used to waterproof the diaphragm walls of the vehicle underpass and the wall-to-wall construction joints were treated with Xypex Dry-Pac in pre-formed U-shaped grooves. Xypex was the stand-alone waterproofing system for the walls of this project.

    Read More

  • Qujiang Reservoir

    Xi'an, Shaanxi, China

    Built in 1990, the Qujiang Reservoir was the biggest in Xi’An. Over time, cracks and leaking appeared on the surfaces of the channel leading to the reservoir. Xypex Concentrate, Modified, and Patch'n Plug were used to repair and waterproof the defective areas.

    Read More

  • Raccoon Creek Water Treatment Plant

    Summerville, Georgia, USA

    306,000 lbs. of Xypex Megamix ll were used to rehabilitate the Raccoon Creek Water Treatment Plant in Summerville, GA. An engineering study determined that the superior bonding, chemical durability, and high strength of Megamix ll would completely repair the structure’s deteriorated concrete and bring it up to EPA standards. 

    Read More

  • Radisson Hotel

    Dhaka, Bangladesh

    The water garden feature of this five-star hotel in Dhaka was repaired and waterproofed using Xypex Crystalline Technology and Xypex products.

    Read More

  • Railway Tunnel

    France

    Xypex products were used to waterproof and protect the walls and ceiling of this railway tunnel.

    Read More

  • Ras Laffan Reservoir

    Ras Laffan, Qatar

    The Ras Laffan Reservoir, part of the highly prestigious Ras Laffan C project, will hold 63 million gallons and produce 275,000 m3 of potable water per day by 2011.

    Read More

  • Rattanakosin Wastewater Treatment Plant

    Banglampoo, Thailand

    Xypex Concentrate was used on 30,000 m2 of concrete to prevent leakage in this new wastewater treatment plant.

    Read More

  • Repsol Fuel Station

    São Paulo, Brazil

    Xypex Quick Set, a clear, surface-hardener, was applied over the concrete slab of this fuel station.

    Read More

  • Reservoir Du Watermael Beek

    Belgium

    Xypex Concentrate was used to waterproof and protect the walls and slab of this reservoir.

    Read More

  • Reservorio Bella Vista

    Guayaquil, Ecuador

    This reservoir, which has a capacity of 25,000 cubic metres, is one of several in Ecuadors Master Plan for the supply of potable water to the city of Guayaquil. During the initial filling of the reservoir, it was found that there was substantial loss of water. This problem was solved by using the Xypex crystalline waterproofing system. 

    Read More

  • Residential Complex

    Warsaw, Poland

    The foundation walls and slab of this residential housing complex were waterproofed with the Xypex system.

    Read More

  • Residential Roof Decks

    Tamuning/Nimitz Hill, Guam

    Xypex Crystalline Technology and products were selected to waterproof and protect the roof decks of several residential buildings.

    Read More

  • Revelstoke Canyon Dam

    Revelstoke, British Columbia, Canada

    Six 100 ft.2 shafts were waterproofed with the Xypex system. This dam is 440 ft. high and holds 1.5 million acre feet of water.

    Read More

  • Richi Court Building

    Bangkok, Thailand

    The foundation walls and the roof water tank of this new building in Bangkok were treated with a two coat application of Xypex products. Total area treated was 3,000 m2 (32,300 sq. ft.).

    Read More

  • Rinkai Road Tunnel

    Tokyo, Japan

    This Tokyo road tunnel, located on the shoreline of re-claimed land is up to 30 m below sea level. 

    Read More

  • Rio Colorado Aquaduct

    La Pampa, Argentina

    Tie holes and other surface cavities were repaired with Xypex Patch'n Plug before the application of Xypex Concentrate.

    Read More

  • River Rock Casino

    Richmond, BC, Canada

    Xypex Admix C-1000 was blended into the concrete mix to waterproof and protect the concrete of the foundation walls.

    Read More

  • River Sotke Tunnel

    Estonia

    Xypex Concentrate was used to waterproof the walls and ceiling of this river tunnel. Xypex Patch'n Plug was used to repair cracks.

    Read More

  • Robina Town Centre

    Robina, Australia

    To date, 13,000 m3 of concrete have been dosed with Xypex Admix C-2000, including the exposed deck and walls, and fire service tanks. Xypex Concentrate slurry has been used along with Xypex Dry-Pac in the joints. This project is on-going with plans for Xypex to be used in the sewage treatment plank and rail link to Brisbane.

    Read More

  • Rosamond Gifford Zoo – The Penguin Coast Exhibit

    Syracuse, New York, USA

    The exhibit was closed to find the sources of the leakage. Xypex products, including Xypex Concentrate, Admix, Patch'n Plug and FCM 60 were used to stop the seepage and leaks emanating from the concrete slab, the exterior walls and around the glass areas.

    Read More

  • Rosario Water Treatment Plant

    Rosario, Santa Fe, Argentina

    Xypex products were used to waterproof the concrete of this 10,000 m2 water treatment plant.

    Read More

  • Rosemont Development – Private Residence

    Bellevue, Washington, USA

    Xypex Admix C-1000 was blended into the concrete mix to waterproof the garage wall against a soil surface.

    Read More

  • Roxboro Materials

    Roxboro, North Carolina, USA

    5,000 cu. yds. of Xypex Admix C-1000 was blended into the concrete for the foundation of the coal unloader and the lime processing plant of this power plant.

    Read More

  • Russian Central Bank

    Moscow, Russia

    The Russian Central Bank is located adjacent to the Moscow River. Its foundation is 10 m below ground level and subject to considerable hydrostatic pressure resulting in heavy leakage. 

    Read More

  • Saifee Hospital

    Mumbai, India

    The Saifee Hospital is a wonderful piece of architecture at Charni Road in Mumbai. The entire structure is built with a blend of Fatemi and modern architecture and has become an important landmark. 

    Read More

  • Saint Mary’s Abbey

    Ireland

    This retail and apartment development complex, located close to the River Liffey, is an on-going Xypex project. To date, 9,820 kg of Xypex Admix has been used to waterproof areas such as the basement slab, 6 m below ground level and 4 m below the water table and perimeter wall.

    Read More

  • Sakosa Ind. Yarn And Textile Plant

    Izmit, Turkey

    The below grade air conditioning canals of this plant were waterproofed with the Xypex system – Xypex Concentrate, Modified and Patch'n Plug. This plant produces the flexible fiber lining for tires.

    Read More

  • San Diego Zoo – Polar Bear Tank

    San Diego, California, USA

    This tank was treated with both Xypex Concentrate and Modified at an application rate of 1 lb./6 sq. ft.

    Read More

  • San Juan Community College

    San Juan, Puerto Rico, USA

    Xypex products were used to waterproof and protect this 3,500 sq. ft. retaining wall.

    Read More

  • Sandy Bay Seawall

    Tasmania, Australia

    An existing seawall had become delapidated due to decades of constant, severe exposure to wind, tides and wave action.

    Read More

  • Santa Isabel Wastewater Treatment Plant

    Santa Isabel, Puerto Rico

    Xypex products were specified and used to waterproof the digester tank (12,155 sq. ft.), the surge-reverse-batching tanks, and the lift pump station and filter of this wastewater treatment plant.

    Read More

  • Santa Monica Wastewater Treatment Plant

    Campinas, Brazil

    Xypex Patch'n Plug was applied to the construction joints followed by an application of Xypex Concentrate and Modified to protect and waterproof the concrete.

    Read More

  • Santa Rosa Manhole Program

    Santa Rosa, California, USA

    Xypex products were an integral part of the City of Santa Rosa's infiltration / inflow reduction program. This was an ongoing program with approximately 300 manholes scheduled for renovation and waterproofing annually. Over 3,000 manhole structures were successfully sealed with Xypex products.

    Read More

  • Sanyo Home Appliance Factory – Phase 1 & 2

    Bien Hoa, Dong Nai, Vietnam

    After waterproofing the Phase 1 office roof with a bitumenous membrane during the rainy season, the portion of the factory gutter switched to using Xypex to reduce application time. Following the excellent results, the main contractor, Obayashi Corporation continued to select Xypex to waterproof the factory gutters and a small roof at the Phase 2 of this factory. 

    Read More

  • São Paulo Metro System

    São Paulo, Brazil

    The São Paulo Metro is the main rapid-transit system in the city of São Paulo and the largest in Brazil. The Metro has a length of 74.3 kilometres (46.2 miles), distributed into five lines with 64 stations.

    Read More

  • Sea World – Polar Bear Shore

    Gold Coast, Australia

    Sea World is a marine mammal park, oceanarium, and theme park located on the Gold Coast, Queensland, Australia. It features one of the most technologically advanced exhibits for Polar bears in the world.

    Read More

  • Second Orinoco River Bridge

    Ciudad Guayana, Venezuela

    The general contractor, Constructora Norberto Odebrecht, S.A., concerned about water seepage and possible corrosion of the reinforcing steel in the concrete forming the base for the railway, used Xypex to waterproof and protect it.

    Read More

  • Secondary Containment Tanks

    Slovakia

    After pressure washing, the floors and walls of these collection pits were treated with Xypex Concentrate and Modified. All joints and cracks were cut, filled and sealed with Xypex Dry-Pac.

    Read More

  • Sempra Energy Natural Gas Terminal

    Ensenada, Mexico

    More than 25,000 lbs. of Xypex Concentrate were used to protect the concrete from the harsh marine environment and the potential for deterioration due to chloride exposure. The breakwater is 1,300 meters long.

    Read More

  • Seneca Wastewater Treatment Plant

    Minnesota, USA

    Xypex products were used to repair the extensive cracking (5,000 linear feet) in pipe galleries at the old section of this plant. Xypex crystalline waterproofing system was also used to coat the chlorine contact chambers and other structures in the new section of the plant.

    Read More

  • Settling Tanks – Minerven

    El Callao, Venezuela

    After 15 years of use the sediment depositories showed serious signs of damage and leakage. This was primarily due to the use of cyanide in the separation process of the gold ore. The bottom slab and walls were treated with Xypex Concentrate and all the joints with Xypex Dry-Pac.

    Read More

  • Sewage Pipeline

    Krapina, Croatia

    This concrete pipeline in North West Croatia exhibited leakage through various joints. This problem was solved successfully by using Xypex Patch'n Plug and Xypex Concentrate. 

    Read More

  • Sewage Reticulation Plant

    Puckapunyal, Australia

    Repair and restoration of this 50 year old plant, located at the Puckapunyal Royal Australian Army Base, was completed using Xypex Patch'n Plug and a two coat application of Xypex Concentrate and Modified. 

    Read More

  • Sewage Treatment Plant

    Bahia Blanca, Buenos Aires, Argentina

    Xypex products were successfully used to waterproof and protect the concrete of this sewage treatment plant.

    Read More

  • Sewage Treatment Plant

    Slovakia

    Xypex Concentrate and Modified were applied to 3 sludge digester tanks and one storage tank covering a total area of 2,472 m2. Xypex Patch'n Plug and Dry-Pac were used to repair the cracks and grooves.

    Read More

  • Sewer Tunnels

    Madeira Islands, Portugal

    Over 20,000 lbs. of Xypex material was used in the shotrcrete to stop water infiltration into the tunnels and provide protection from the corrosive effects of hydrogen sulfide gas.

    Read More

  • Sewerage Holding Tank

    Ireland

    This reinforced concrete tank, 12m x 8m x 6m, was built as a sewage holding tank for a large housing development. The sewage was then pumped to the process station. The adjacent river and the nature of the effluent made it imperative that no leakage occur from the tank. Admix C-1000 NF (600 kg) was used to waterproof the concrete and prevent leakage.

    Read More

  • Seyring Fire Station

    Seyring, Austria

    Approximately 3,000 kg of Xypex Admix C-1000 and Xypex Concentrate was used in the construction of the basement and walls of this Fire Station. Because of the high groundwater level (one metre below ground level), the Xypex crystalline waterproofing system was critical.

    Read More

  • Shahu Smarak Chhatrapati Shivaji Memorial

    Kolhapur City, India

    Xypex Concentrate was selected to rehabilitate and waterproof the terrace slab and toilets of this Memorial structure which was leaking heavily.

    Read More

  • Shanghai Changshu Subway Station

    Shanghai, China

    Because previous systems had failed, Xypex Crystalline Technology was specified to stop water from entering into this subway station. Xypex Patch'n Plug and Xypex Concentrate were used to repair cold joints between the ceiling and wall and to repair cracks throughout the walls of the structure.

    Read More

  • Shanghai Light-Duty Railway – Mingzhu Line

    Shanghai, China

    Xypex products were used to waterproof the basement floors of both the Boaxing Road and the Chang Ning Road railway stations.

    Read More

  • Shanghai Metro Turnaround

    Shanghai, China

    The tunnels and the exit walls and floors of the Longdong Road turnaround were waterproofed with Xypex Concentrate.

    Read More

  • Shebin El Koum Sewage Station

    Cairo, Egypt

    The concrete in this major wastewater treatment plant of 35,000 m2 was waterproofed and protected with Xypex products.

    Read More

  • Shoaiba Desalination Plant

    Saudi Arabia

    This plant is considered one of the largest desalination units in the world. Xypex was used to waterproof the pump house located below sea level and the concrete canals for the sea water inlet and outlet.

    Read More

  • Shopping Centre Car Park

    Farnborough, United Kingdom

    Xypex products were used successfully to seal persistent water leaks in the underground car park of this newly built shopping centre. The water seepage was originating at the joint interface between the block wall and the floor. 

    Read More

  • Showa Glove Factory

    Binh Duong Province, Vietnam

    Xypex is again selected to waterproof and protect all water tanks, a water treatment plant, and a waste treatment plant of the factory. Total area is approximately 2,400 m2 with 7,054 tie holes, and 694 meters of construction joints. All construction joints are sealed by Xypex Concentrate Dry-Pac method without use of waterstops. Work was completed in July 2004.

    Read More

  • Singapore Marina Barrage

    Singapore

    After 20 years of meticulous planning, design and construction, the $220+ million Marina Barrage has recently become operational, creating Singapores 15th reservoir out of the iconic Marina Bay.

    Read More

  • Sirca Commercial Centre

    Valera, Venezuela

    The concrete roof slab of this exposed parking area was waterproofed with Xypex Concentrate as a preventative measure.

    Read More

  • Skala – Nemsova Motorway Bridge

    Slovakia

    This motorway concurrently forms a flood barrier to the Vah River. A two-coat application of Xypex Concentrate and Modified was used to waterproof the run-off channels and pits where highway water, carrying oils and chemicals are collected. The columns on several of the bridge sections were also treated with a two-coat Xypex application.

    Read More

  • Slovak Savings Bank Taxation Office Complex

    Poprad, Slovakia

    To protect the concrete and prevent ground water seepage, Xypex Concentrate and Modified were applied to the below-grade walls and slab of this Bank building. Approximately 28,000 sq. ft. of Xypex coating and 4,800 lineal ft. of Xypex joint work were required.

    Read More

  • Sludge Facility

    Homestead, Florida, USA

    Xypex products were used to waterproof the interior walls of the tanks for phase 3 of this wastewater treatment plant extension. The top four feet of the Xypex application was coated with coal-tar epoxy.

    Read More

  • Sofia Airport Reservoir

    Sofia, Bulgaria

    This new reservoir with attached concrete channels was waterproofed in a two-coat application of Xypex Concentrate and Xypex Modified. The joints were treated according to the specification.

    Read More

  • Somerset State Correction Institute

    Somerset, Pennsylvania, USA

    Xypex Admix was used in lieu of a coating because of the ease of application through a winter construction schedule. Considerable labor-saving costs were realized.

    Read More

  • South District Wastewater Treatment Plant

    Miami-Dade, Florida, USA

    As Miami-Dade County’s population continues to increase, using reclaimed water enables the MDWASD to provide a sustainable water resource for its environment and its future.

    Read More

  • South Weber Water Treatment Tank

    South Weber, Utah, USA

    180 cu. yds. of concrete was dosed with Xypex Admix to waterproof and protect the walls of this tank.

    Read More

  • Sports Stadium

    Celje, Slovenia

    Xypex Admix C-1000 was blended into the concrete mix and installed as an integral part of the concrete slab to waterproof and protect it. Xypex Concentrate and Modified were applied to the wall and Admix was used in the base slab of the below-ground transformer room to prevent any leakage.

    Read More

  • St. Clair County Administration Basement

    Port Huron, Michigan, USA

    Xypex Admix C-2000 was blended into the concrete mix to waterproof and protect the basement slab of this structure. The basement is 13 ft. below the river and has to withstand anticipated flood levels. 

    Read More

  • St. George’s Residential Care Facility

    Bermuda

    Xypex Admix C-1000 was used to waterproof the tank, ground floor slab and the exterior of this care facility.

    Read More

  • Stadium Australia

    Homebush Bay, Australia

    The ANZ Stadium, also known as Stadium Australia, formerly known as Telstra Stadium, is a multi-purpose stadium located in the Sydney Olympic Park precinct of Homebush Bay. The stadium, which in Australia is sometimes referred to simply as the "Olympic Stadium", was completed in March 1999 to host the 2000 Summer Olympics. The sweeping, slouch-hat shape of Sydney’s Olympic Stadium was built to seat more than 110,000 for the 2000 Games, making it at that time the largest Olympic Stadium ever built as well as the largest stadium in Australia.

    Read More

  • Star City

    Kuala Lumpur, Malaysia

    Xypex Admix was used to waterproof and protect the foundation walls and floor of this office building and shopping centre.

    Read More

  • Star Palace Hotel Pool

    Cancun, Mexico

    Xypex Concentrate was used to waterproof and protect the large swimming pool in this new hotel.

    Read More

  • Subaru-Isuzu Automotive Plant

    Lafayette, Louisiana, USA

    The Xypex crystalline system was applied to the interior surfaces of all paint and sludge pits at this new Subaru-Isuzu plant in Indiana. In addition to sealing against infiltration of groundwater, the Xypex system was used to prevent the seepage of solvents from the tanks into the environment. The total area treated was approximately 4,650 m2 (50,000 sq. ft.).

    Read More

  • Sugagawa City Sewage Treatment Plant

    Sugagawa, Japan

    Xypex Concentrate was used to waterproof and protect the basement wall of this plant.

    Read More

  • Sun Wah Tower

    Ho Chi Minh City, Vietnam

    After its completion of the works in the basement, the main contractor, Shimizu Corporation switched to using Xypex for the waterproofing of the 3rd floor and the roof water tanks. Since leakage from these above grade tanks will definitely cause serious damages and inconveniences to the building occupants, the contractor was determined to use only the very best product available.

    Read More

  • Susten Pass Road Tunnel

    Innertkirchen, Switzerland

    The concrete of this 1949 tunnel deteriorated resulting in water seepage and, with freezing temperatures became a traffic hazard. The design of the tunnel did not comply with current building standards resulting in the concrete being removed. 

    Read More

  • Svetly Yakutia Water-Purifying Complex

    Svetly Yakutia, Russia

    The epoxy coating that had originally been applied to the surface of the concrete to prevent water penetration, failed. Xypex was selected to remedy the problem. The epoxy surface was removed, and cracks and leaks were repaired with Xypex Patch'n Plug followed by a two coat application of Xypex Concentrate and Modified.

    Read More

  • Svobodka Waterworks

    Svobodka, Czech Republic

    Xypex Concentrate and Patch'n Plug were used on this water treatment plant to seal the joints and against seepage. 100 meters of crack repair using Xypex products was also carried out.

    Read More

  • Swimming Pools

    Bulgaria

    15 hotel swimming, wading and decorative pools across Bulgaria were repaired and waterproofed using Xypex Patch'n Plug, Concentrate and Modified.

    Read More

  • Swiss Bank Tower

    Panama City, Panama

    Xypex Concentrate and Modified were applied to this concrete slab to prevent infiltration of rain water into the underground parking garage.

    Read More

  • Swissôtel

    Seoul, Korea

    The basement foundation walls and slabs, swimming pool, machine rooms, pits and parking deck of this hotel owned by Swiss Air were waterproofed with the Xypex crystalline system. A total of 28,725 m2 (309,200 sq. ft.) were treated.

    Read More

  • Switching Station KV

    Czech Republic

    Xypex Concentrate and Modified were spray-applied to the reinforced concrete of the underground pits, transformers, inductor sites and construction joints to prevent the leakage of transformer oil into the surrounding soil. The project took more than one year to complete.

    Read More

  • Sydney Airport Tunnel – M5 Motorway

    Sydney, Australia

    Xypex was used to meet the concrete waterproofing specifications for the freeway (road) tunnel which runs below the Cooks River beside Sydney’s Mascot Airport. The project involved two contracts – one for 5,000 m3 (Cooks River trough section) and another for 1,200 m3 (Turella Shaft Tunnel).

    Read More

  • Sydney Harbour Tunnel

    Sydney, Australia

    Commencing in September of 1991, repair systems using Xypex Concentrate and Xypex Patch’n Plug were used as part of an ongoing program of repair and maintenance of the North and South land driven tunnels and transition tunnels of this renown structure.

    Read More

  • Sydney Opera House

    Sydney, Australia

    The Sydney Opera House is a multi-venue performing arts centre and a modern expressionist design, with a series of large precast concrete "shells", each composed of sections of a sphere of 75.2 metres (246 ft 8.6 in) radius, forming the roofs of the structure, set on a monumental podium. It is supported on 588 concrete piers sunk as much as 25 m (82 ft) below sea level. Xypex Admix was used to waterproof 200 m3 of concrete in this famous Australian landmark.

    Read More

  • Sydney’s Taronga Zoo

    Sydney, Australia

    Xypex Admix C-1000 was added to the 300 m3 of concrete used in the construction of the clarifier and treatment tanks. These tanks contain potable water for the zoo’s animals.

    Read More

  • Syncrude Ue-1 Oil Sands Project

    Fort McMurray, Alberta, Canada

    A two-coat application of Xypex Concentrate and Modified was applied to the walls of the cooling tower basin. A total of 80,000 ft.2 was treated.

    Read More

  • Taj Indi One Motel

    Bangalore, India

    Water tanks, sump pits, bathroom floors and terraces were all treated and waterproofed with Xypex Concentrate.

    Read More

  • Taman Anggrek Shopping Mall

    Jakarta, Indonesia

    Xypex projects were used to waterproof the basement and tunnels of this shopping mall which also includes 8 condominium towers.

    Read More

  • Tan Thuan Export Processing Plant

    Nha Be, Vietnam

    Xypex materials and technical support were selected to repair the leaks caused by high water pressure on the exterior faces and construction joints of 11 tanks. Xypex was also chosen because of its resistance to aggressive chemicals.

    Read More

  • Tata Housing Development “Enterprise Centre”

    Mumbai, India

    A single coat application of Xypex Concentrate was applied to the entire concrete of this basement roof slab.

    Read More

  • Tatuquara Reservoir

    Curitiba, Brazil

    Xypex Concentrate and Modified were applied to both the negative and the positive side of this reservoir to waterproof and protect the concrete structure.

    Read More

  • Teharje Monument

    Teharje, Slovenia

    Xypex products were applied to the exterior concrete surface of the monument roof which was leaking heavily.

    Read More

  • Teksons Building Quarters

    India

    Xypex products were used to waterproof the terrace garden, planters, roof-top swimming pool and the overhead water tanks. Xypex was selected, not only because of its proven waterproofing capabilities but also because the Xypex crystalline process helps prevent the deterioration of the reinforcing steel.

    Read More

  • Telefonica Del Peru

    Lima, Peru

    Xypex Patch'n Plug and Xypex Concentrate were used to repair and waterproof this and many other vaults in Lima.

    Read More

  • Telefonos De Mexico Vaults

    Mexico City, Mexico

    Xypex Patch'n Plug and Xypex Concentrate were used to stop water infiltration into substations throughout Mexico. Careful research by Telefonos de Mexico resulted in the selection of Xypex over other products in the market.

    Read More

  • Telekom Exchange

    Cyberjaya, Malaysia

    Telekom Exchange is the largest integrated solutions provider in Malaysia, and one of Asia's leading communications companies. Xypex Admix C-2000 NF was used to waterproof and protect the exposed reinforced concrete of the roof deck.

    Read More

  • Television Networks – Parking Garage

    Paris, France

    Located on the banks of the Seine, the headquarters of one of France’s premier TV Networks developed severe water ingress in its three storey below-ground car park. 

    Read More

  • The Arab Bank

    Cyprus

    Xypex was used to waterproof the diaphragm walls and a dry scatter of Xypex Concentrate between the blind and the slab, waterproofed the floor area.

    Read More

  • The Barbados Pavilion

    Barbados

    Xypex Admix was used in all basement work including the basement reinforcements of this recently renovated historical building. The improvements elevated this membership and business facility to five-star status.

    Read More

  • The Brook Building

    Addis Abeba, Ethiopia

    The new Brook Building in Addis Ababa was considered a very high profile project and stringent guidelines were imposed for the specification of all products. Xypex was selected as the preferred waterproofing technology and Xypex Concentrate was applied to the entire basement and balconies.

    Read More

  • The Max Condominiums

    Vancouver, British Columbia, Canada

    Xypex Concentrate was used on all exposed above-ground construction joints to protect suites from water penetration. Xypex Patch'n Plug was used to patch and waterproof the tie holes in the underground parkade.

    Read More

  • The Metropolitan Towers

    Ho Chi Minh City, Vietnam

    After the construction is near completion, various cracks occurred at the basement due to structural settlement. Xypex was contacted by Leighton Asia Ltd. to repair 4 newly waterproofed tanks and septic tank of this prestigious high rise office building from the exterior against water pressure in 1997, using Xypex Concentrate and Patch’n Plug. 

    Read More

  • The Miro Condominiums

    Vancouver, British Columbia, Canada

    Xypex Concentrate was used to waterproof all above-grade construction joints exposed to weather. Xypex Patch'n Plug was used to patch and waterproof all tie holes.

    Read More

  • The Municipal House

    Prague, Czech Republic

    The Municipal House (built 1905 - 1911) is one of Prague’s most valuable cultural and architectural treasures. During the building’s total reconstruction, Xypex products were used to ensure the waterproofing qualities of the reservoirs and utility tunnels under the buildings.

    Read More

  • The Rodney Barge Inn

    United Kingdom

    This old Inn, built adjacent to a canal, suffered persistent flooding in the cellar, varying from a few inches to several feet. The walls were in a very poor state and with dozens of leaks. The leaks were sealed using Xypex Patch'n Plug and all surfaces were then slurry coated with Xypex Concentrate. The coating was cured with Xypex Gamma Cure.

    Read More

  • The Sands Casino

    Macau

    The foundation of The Sands Casino was subject to high hydrostatic pressure. Xypex Admix C-1000 NF was specified and used to waterproof over 10,000 m3 of foundation concrete. Xypex Patch'n Plug and Xypex Concentrate were used to repair the cracks and joints.

    Read More

  • The Supreme Residence

    Jerusalem, Israel

    Xypex products were used throughout all below grade area of this luxury condominium complex, including the foundation, parking structure, elevator pits and water reservoir. The Xypex repair system was employed to address all joints, tie holes and defects in the concrete. Over 5,000 m2 were treated with Xypex Concentrate, Modified and then cured with Gamma Cure.

    Read More

  • Thủ Dầu Một Park Swimming Pool

    Ho Chi Minh City, Vietnam

    The perimeter walls of this swimming pool were seriously leaking due to a defective concrete pour. All defective concrete was removed and Xypex Patch'n Plug and Xypex Concentrate were used to repair and waterproof 80 linear meters of construction joints.

    Read More

  • Tirgu Jiu Hydro Power Plant

    Tirgu Jiu, Romania

    The upstream and downstream pressure walls of this hydro power station were waterproofed with 700 kg of Xypex products prior to the second phase river diversion, which put the structure under pressure.

    Read More

  • Townhouses – 28th And Madison

    Seattle, Washington, USA

    These townhouses backed onto a concrete slab. The slab had hairline cracks, mostly from utility box knock-outs and pipe penetrations. The developer requested Xypex Admix C-1000 but because the topping deck was so thin in many places, the Xypex representative recommended an alternate Xypex system: cracks were treated with Xypex Concentrate, with Xypex DS-1 as the primary waterproofing feature.

    Read More

  • Townworks District Heating Chambers

    Krefield, Germany

    The Xypex system was used for the restoration and waterproofing of these underground heating chambers in Krefeld. 

    Read More

  • Traders Hotel

    Abu Dhabi, Dubai, United Arab Emirates

    In this prestigious 301 room hotel, Xypex Concentrate and Patch‘n Plug were used to waterproof this rooftop swimming pool.

    Read More

  • Transformer Stations

    Ljubljana, Slovenia

    The chemical and chloride protection ability of the Xypex Crystalline Technology was put to use in repairing the deteriorating concrete structure underneath the transformers at this electrical facility. Xypex Concentrate and Patch’n Plug were applied to three transformer stations to prevent oily substances leaching into the surrounding soil.

    Read More

  • Tribhuvan International Airport – Fire Station

    Kathmandu, Nepal

    Xypex products were applied to the external surfaces of horizontal beams and vertical columns to form a waterproof backing for brick work. Tie beams, foundation and roof slabs of the fire station and maintenance building were also treated with Xypex.

    Read More

  • Tribuvan International Airport – Roof Decks

    Kathmandu, Nepal

    All construction strips, wall and floor joints, metal pipe joints and blow holes were treated with Xypex Concentrate Dry-Pac. The surfaces of the terraced roofs were routed out and cleaned followed by a two-coat application of Xypex Concentrate and Modified.

    Read More

  • Tsuen Wan Station

    Hong Kong

    Tsuen Wan is the northern terminus of the MTR Tsuen Wan Line in Hong Kong. It is the only station on the Tsuen wan Line that is at ground level.

    Read More

  • U.S. Navy – Maanot Reservoir

    Naval Magazine, Guam

    Xypex FCM 40 was used to repair the cracks and joints in the concrete walls and floors of two 500,000 gallon tanks in this Navy reservoir. A two-coat application of Xypex Concentrate and Modified was then applied to waterproof and protect the concrete.

    Read More

  • Umi Bridge

    Papua New Guinea

    This bridge structure on the Markham Valley Highway showed signs of leeching and water permeation on the soffit of the deck, resulting in fine cracking of the concrete. Xypex Concentrate and Xypex Gamma Cure were selected not only because of their superior waterproofing capabilities but because they could be applied under adverse weather conditions and bridge service would not be interrupted.

    Read More

  • Underground Garage

    Warsaw, Poland

    Xypex Concentrate was applied to the ceiling of this underground garage within this block of buildings.

    Read More

  • Underground Passage

    Vilnius, Lithuania

    The concrete structures of this new underground passage were waterproofed with Xypex Admix C-1000. The technological joints were waterproofed by cutting a slot in the set concrete and filling it with Xypex Concentrate Dry-Pac. A total of 3,000 kg of Xypex Admix and 250 kg of Xypex Concentrate were used.

    Read More

  • Underground Shelter

    Bat Yam, Israel

    Xypex was employed initially to repair construction joints and cracks and Xypex Concentrate and Modified were then spray applied to the all exterior below-ground foundation walls as well as the base slab to prevent water ingress.

    Read More

  • United Nations Building

    Barbados

    Xypex Concentrate was used to waterproof and protect the planters on the outside of the building, on all floors. Xypex was also used in the fountains.

    Read More

  • United Square Shopping Centre

    Singapore

    Xypex Concentrate was used to waterproof the floor under the tiled hallway of this shopping centre.

    Read More

  • University of Florida – Filtration Tank

    Jacksonville, Florida, USA

    Xypex Concentrate, Patch'n Plug and Modified were used to waterproof the outside of the filtration tank for this very large swimming pool.

    Read More

  • University Of Lima

    Lima, Peru

    Xypex Patch'n Plug was used to repair cracks in these planters. A two-coat application of Xypex Concentrate and Modified was then applied to waterproof the structures.

    Read More

  • Upper Vah Cascade

    Krpelany-Sucany, Slovakia

    The joints and cracks on the diversion channel of the dam, which started operation in 1957, required repair to prevent the leaking of water into the surrounding landscape and thereby prevent any washout of the underground. Xypex Concentrate, Admix C-1000, and FCM were used in the repair process.

    Read More

  • Vacation Home

    Bermuda

    Admix C-2000 was used extensively during the construction of this vacation home and swimming pool, to waterproof and protect the concrete.

    Read More

  • Vaci Avenue Business Center – Underground Garage

    Budapest, Hungary

    The ceiling of this multi-level underground parking garage was exposed to constant water leakage from the garden above. Xypex products were used to patch the cracks and waterproof the concrete to stop the leaking – after other products had failed.

    Read More

  • Vancouver Art Gallery

    Vancouver, British Columbia, Canada

    Vancouver's historic court house underwent a major alteration over a three year period to become the new Vancouver Art Gallery. 

    Read More

  • Vancouver Seabus Floating Docks

    Vancouver, British Columbia, Canada

    Xypex products were applied to the underside of the two large floating docks after the post-tensioned cables were found to be no more than 1/2 inch from the bottom surface. The Xypex system was used as protection against further chloride attack on the steel and post-tensioned cables.

    Read More

  • Venetian Cotai

    Macau

    Xypex products were used to waterproof and protect the foundation walls and slab of this structure.

    Read More

  • Viaduct Harbour

    Auckland, New Zealand

    This area in downtown Auckland, a development of mostly upscale apartments, office space and restaurants, was home to the America’s Cup Defence and Challenging Teams. 

    Read More

  • Vicksburg Sewer Main

    Vicksburg, Mississippi, USA

    Xypex Admix C-1000 was added to the concrete pipe at a rate of 3% by weight of portland cement. Xypex Admix was selected over a traditional protective coating to provide chemical protection and to prevent water ingress and egress.

    Read More

  • Victoria And Alfred Site

    South Africa

    Admix C-1000 NF is being used to waterproof two tunnels as part of a massive redevelopment of Cape Town Harbour. The two tunnels are to be located below the water channel and used to join several man-made islands. Xypex Concentrate is also being used as a Dry-Pac in pre-formed construction joints.

    Read More

  • Vietcombank Tower

    Ho Chi Minh City, Vietnam

    For the Vietcombank Tower, Xypex products were applied by Bachy to repair defective concrete at all leakage points in the diaphragm wall construction joints and to seal all rebar penetration along the perimeter of the basement slab. The successful completion of these repairs in November 2012 resulted in the decision to use Xypex Concentrate to waterproof all four levels of diaphragm walls. The project is ongoing.

    Read More

  • Vila Amelia Reservoir

    Vila Amelia, Brazil

    Xypex Concentrate and Modified were spray-applied to both the negative and the positive side of the top slab of this reservoir to waterproof and protect it.

    Read More

  • Vision City

    Kuala Lumpur, Malaysia

    This multi-purpose structure used Xypex Admix to waterproof and protect the foundation walls and slabs.

    Read More

  • Visitors Marina - Darling Harbour

    Sydney, Australia

    Xypex Admix C-2000 was used to waterproof and prevent the ingress of chlorides into these pre-stressed, pre-cast units. The Xypex assisted in providing long-term durability to this floating concrete structure.

    Read More

  • Volksbank

    Croatia

    The old mortar on the walls and floor were leaking badly in many places. Xypex Patch'n Plug and Xypex Concentrate were used to repair 100 m of cracks and joints. The entire surface was then treated with a two-coat application of Xypex Concentrate and Modified.

    Read More

  • Volkswagen Plant

    Buenos Aires, Argentina

    Xypex Concentrate and Modified were applied over all the concrete surfaces of this industrial effluents-treatment plant to waterproof and protect it against aggressive chemicals. Xypex Concentrate was also used in the valve chambers.

    Read More

  • Votive Temple To The Virgin Of Coromoto

    Guanare, Venezuela

    The concrete slabs of the underground library and conference rooms were leaking badly due to the high water table of the surrounding area. Xypex Dry-Pac was applied to the joints, followed by a coat of Xypex Concentrate.

    Read More

  • Vuoli 1 Tunnel – Vuosaari Harbour

    Finland

    Xypex Admix C-1000 NF was used to waterproof and protect the 50 mm thick shotcrete lining on the rail and road tunnel under the Helsinki harbour. The mix-design used 470 kg of Portland cement per m3 and the admix was dosed at 1.1% (5 kg) per m3.

    Read More

  • Warsaw Metro Station A-15 'Ratusz'

    Warsaw, Poland

    The Xypex system was used to waterproof the concrete of the entire subway station, including the floors, walls and ceilings.

    Read More

  • Washington D.C. Metro System

    Washington, D.C., USA

    Xypex products were specified by Bechtel Corp and the Washington Metropolitan Transit Authority for use at various locations of the metro area subway system, including sections in central Washington D.C., Bethesda (Maryland), Chevy Chase (Maryland) and Alexandria (Virginia). 

    Read More

  • Wastewater Reservoir

    Gent, Belgium

    The Xypex system was used in the repair and upgrading of this concrete structure which had many cracks and exhibited deterioration of both the concrete and the rebar. 

    Read More

  • Water Conserv II

    Orlando, Florida, USA

    The underground piping for this pollution control facility consists of steel pipe sections which are coated with a thin layer of cement mortar. This mortar layer was very porous and was spalled in some areas. 

    Read More

  • Water Supply Valve Chamber

    Hagley, United Kingdom

    This valve chamber is built 12 metres (40 ft) below ground level in a location where the water table is consistently very high. Many previous attempts had been made to prevent water ingress, but the chamber continued to suffer flooding due to infiltration through the concrete. 

    Read More

  • Waterfront Centre

    Vancouver, British Columbia, Canada

    Ten large thermal storage tanks, ten elevator pits and four sump pits were waterproofed with Xypex products at this prominent hotel and office complex located on Vancouver's harbour waterfront. The thermal chambers are below sea level and comprise part of the concrete foundation structure. 

    Read More

  • Werribee Zoo

    Victoria, Australia

    A history of successful projects with Zoos Victoria meant Xypex Australia was entrusted to provide waterproofing solutions for their new Hippo enclosure at Werribee Open Range Zoo.

    Read More

  • Westlink Apartment

    Jakarta, Indonesia

    Xypex products were used to waterproof and protect the foundation floors and walls of this apartment block.

    Read More

  • Willis Building

    London, United Kingdom

    Changing the London skyline, The Willis Building is the fourth tallest building in the city. Its progressive environmental strategy surpasses statutory carbon reduction targets and meets the highest standards for sustainability. Over 15,000 m3 of concrete was used in its construction.

    Read More

  • Wimpey Homes

    United Kingdom

    3,000 kg of Xypex Admix C-1000 NF was used on this prestigious development on the banks of the River Thames. Three large units were constructed, each with underground car parks. The floors and walls of each basement were poured with Admix added to the concrete. Between pours, 800 kg of Xypex Concentrate was applied to all cold joints.

    Read More

  • Winneba Waterworks

    Accra, Ghana

    All cracks in the filtration tanks of this plant were repaired using Xypex Patch’n Plug, followed by a two-coat application of Xypex Concentrate and Modified.

    Read More

  • Wisma Putra

    Putrajaya, Malaysia

    Approximately 7,000 m3 of Xypex Admix C-2000 was blended into the concrete mix and used in the casting of the basement slab, retaining walls and water tanks of these hilltop structures.

    Read More

  • Wolsong Nuclear Plant

    Gyeongju, Gyeongbuk, Korea

    Xypex products were used to repair cracks and coat surface areas in the intake and discharge conduits of this nuclear plant. The conduits are utilized in the process of cooling water.

    Read More

  • World Garden Luxury Apartments

    Kunming, China

    Xypex products were used to waterproof the basement parking garage of this luxury apartment building.

    Read More

  • World Trade Centre

    Mexico City, Mexico

    Mexico City's World Trade Centre is the largest building in Latin America. It is the third tallest building in Mexico City and is 52-story tall. 

    Read More

  • Wuhu Railway Bridge

    Hangzhou, China

    Delamination, pitting, and irregular cracks occurred on the concrete beams of this bridge. Xypex products were used to repair and waterproof the beam and rectify the problems. The application was very successful and resulted in the issuance of a ‘certificate of competence’ by the Hangzhou railway administration as regards ‘Xypex repair techniques for railway reinforced-concrete-beams’.

    Read More

  • Wynn Resorts

    Macau

    Xypex products were used to waterproof and protect the foundation of this resort structure.

    Read More

  • Xenios Building

    Cyprus

    This building was facing continuous rising damp problems. Xypex Patch'n Plug was used for structural repairs to the surface and Dry-Pac was used along the wall and floor joints. Xypex Concentrate and Modified were then applied to the surface to rectify the problem.

    Read More

  • Xibing Hydroelectric Station

    Fujian Province, China

    This hydroelectric station is a research project of the Hydraulic Department of Tsinghua University. Xypex Concentrate was used to the thin-rolled concrete arch at the dam’s surface.

    Read More

  • Xidan Commerce Building

    Beijing, China

    The Xidan Commercial Block is located in the busiest commercial district of Beijing. Three basement floors in this block were waterproofed with Xypex Concentrate. Xypex Patch'n Plug was used for crack repair.

    Read More

  • Yazaki Eds Wire-Harness Factory

    Di An, Binh Duong, Vietnam

    Obayashi Corporation switched to Xypex for the main office roof at this factory after repeated repairs with the membrane system. In addition to waterproofing, the decision to select Xypex is the system offers additional protection to the concrete roof which has many shrinkage cracks due to thermal stress and its 43 m length. The previous waterproofing product used on the underground water tank failed due to the low pH content in the water.

    Read More

  • Yokohama Subway Station

    Yokohama, Japan

    Xypex products were used to waterproof concrete in the subway station located beneath this 70 storey landmark tower, the tallest building in Japan. The station is on the Minatomirai line between Tokyo and Yokohama. It is located four floors below ground level and is subject to considerable hydrostatic pressure.

    Read More

  • Yunnan Electric Power Building

    Kunming, China

    This building is situated on the busiest street in Kunming. Xypex Concentrate was used to waterproof the basement walls and floor. This was the first application of Xypex in Yunnan Province and, because of the success of the treatment, Xypex has since been specified on a number of other major projects in the area.

    Read More

  • Zabeel Park

    Zabeel, Dubai, United Arab Emirates

    Zabeel Park is one of the largest parks in Dubai. Xypex products were extensively used to waterproof and protect the water irrigation reservoirs and water features.

    Read More

  • Zawada Mill-Dam

    Zawada, Poland

    Extreme hydrostatic pressure was causing leakage in the concrete of the pipe gallery. Xypex Concentrate was applied on the interior surfaces to prevent further water infiltration.

    Read More

  • Zbiroh Transformer

    Czech Republic

    Xypex Concentrate and Modified were applied to the refurbished surfaces of the old intercepting traps for transformer oil as well as to the surfaces of the new one.

    Read More

  • Zhuzhou Railway “Guda” Bridge

    Zhouzhou, China

    The “Guda” bridge was built in 1969. Weather conditions over 30 years caused serious carbonation on the main part of the bridge. The concrete cracked badly and was restricting the bridge’s use. Xypex Concentrate and Patch'n Plug were used to repair the cracks and prolong the lifespan of the bridge.

    Read More

  • Zilina River Dam

    Zilina, Slovakia

    Xypex products were used to seal 1,000 lineal ft. of construction joints and 25,000 sq. ft. of surface in the underwater area around the turbo generators of this dam. This dam is the second largest in Slovakia.

    Read More

  • Zrebcovo Dam

    Bulgaria

    The tower, which is part of the Dam structure, had severe leaks below the water level. Xypex Patch'n Plug and Xypex Concentrate were used to stop the leaks.

    Read More

Follow Us